This document provides instructions for assembling and using a hydraulic manhole cover lifter. The lifter has a safe working load of 1.5 tons. To use it, assemble the lifter by sliding the beam through the body and attaching the wheels, handle, and lifting hooks. Clean the keyholes of the manhole cover and insert the keys to lock the lifter in place. Pump the cylinder to raise the cover, then pull the lifter to remove the cover. Release the cylinder valve to lower the cover. Wear protective footwear and ensure the lifting hooks face the correct direction for safety.
This document provides instructions for assembling and using a hydraulic manhole cover lifter. The lifter has a safe working load of 1.5 tons. To use it, assemble the lifter by sliding the beam through the body and attaching the wheels, handle, and lifting hooks. Clean the keyholes of the manhole cover and insert the keys to lock the lifter in place. Pump the cylinder to raise the cover, then pull the lifter to remove the cover. Release the cylinder valve to lower the cover. Wear protective footwear and ensure the lifting hooks face the correct direction for safety.
This document provides instructions for assembling and using a hydraulic manhole cover lifter. The lifter has a safe working load of 1.5 tons. To use it, assemble the lifter by sliding the beam through the body and attaching the wheels, handle, and lifting hooks. Clean the keyholes of the manhole cover and insert the keys to lock the lifter in place. Pump the cylinder to raise the cover, then pull the lifter to remove the cover. Release the cylinder valve to lower the cover. Wear protective footwear and ensure the lifting hooks face the correct direction for safety.
2. Clean out the keyholes of the manhole cover. 3. Fix keys into position and wheel lifter into place. 4. Pump cylinder to raise manhole cover. 5. Once cover is clear of the ground pull the lifter to move the cover. 6. To lower the cover release the cylinder valve.
ALWAYS WEAR PROTECTIVE FOOTWARE
THIS TOOL HAS A SAFE WORKING LOAD OF 1.5 TONS ASSEMBLY INSTRUCTIONS
Slide the beam through the body
Slide lifting hooks on either side. Ensure hooks face towards the back wheel
Attach wheels and handle
Fit keys into cover and move lifter into position
Pump jack handle to lift cover
Pull lifter to remove cover
EXTRA INSTRUCTIONS
1. WEAR PROTECTIVE FOOTWARE
2. ENSURE HOOKS ARE ATTACHED FACING THE CORRECT DIRECTION
3. IF COVER IS STUCK HIT ARROUND ITS EDGE TO BREAK THE
SEAL. IF THIS DOES NOT WORK USE A SEAL BREAKER. DO NOT CONTINUE TO PUMP CYLINDER AS THE LIFTING BEAM WILL BEND