Professional Documents
Culture Documents
使用说明 Instraction
整机型材尺寸 Whole machine profile size
装配说明 Assembly instructions
1, 底座装配 The base assembly
a)材料 material:
材料 material 规格 specifications 数量 quantity 物 料 编 号 备注 note
material
number
铝 型 材 240mm 2
aluminum material
铝 型 材 220mm 2
aluminum material
螺钉 screw M5x10 8
垫片 gasket M5 8
滑块螺母 The M5 18
slider nut
角件 Angle device 2020 4
b)安装 fix:
安装时注意先预留螺母,示意图如下。 When installation note first reserve a
nut, schematic diagram is as follows
d)最终效果:感觉安装得比较平整的话就可以把螺钉拧得紧一点,这样
比较牢固。The result: you can feel more smooth installation screw up tight, it's strong
e)台面安装如图所示:螺钉也不用太紧。螺母座的方向可以随意,滑块
方向如图。 Install countertops as shown: screw also need not too tight.Nut and two direction
can freely slide block direction as shown in figure.
f)最终效果:在安装时可以轴间距可以根据实际情况进行调整。
The result: when installing can axial spacing can be adjusted according to the actual situation.
3,
螺杆和联轴器连接是一定要调整同心哦,顶丝是对边的,两颗顶丝交换
这拧紧。最后固定好后用手匀速的转动螺杆,感觉下阻力是否均匀。
Screw and shaft coupling is must adjust the concentric oh, is on the edge of the top silk, two top silk
exchange to tighten it.Finally fixed at a constant speed with the hand after the rotation of the screw,
feeling the resistance is uniform.
e) 最终效果 The final result:
b) 安装 XZ 组件。如图所示,最上面的光轴支撑座边沿和铝型材顶端对
齐,两轴间距 68mm,装好后要求 X 轴左右移动力度均匀。
XZ installation components.As shown, the top of the optical axis of turning the aluminum top
alignment, alongside two axial spacing of 68 mm, installed demand about the X axis
movement strength evenly.