‘Symptom Test
‘You see unknown frequencies below — | High Resolution Analysis
the running speed. Low Frequency Analysis
“You see a peak (or peaks) that looks like | Synchronous Analysis
aharmonic of the turning speed, but you
are not completely sure. You are trying
to confirm unbalance, misalignment, or
Tooseness.
High Resolution Analysis with 2xTS peak marked
“You need to distinguish between
unbalance versus resonance.
Bump Test (equipment running)
Bump Test (equipment off)
High Resolution Analysis with IxTS peak marked
‘You need to confirm if vibration is
bearing related (non-synchronous).
High Frequency Analysis
Synchronous Analysis
‘You suspect a resonance problem. Bump Test (equipment running)
Bump Test (equipment off)
Coastdown (peak hold)~no tach signal
Coastdown (peak’phase)--tach signal is evailable
"You suspect an electrical problem. __| High Resolution Analysis with 2xTS peak marked
High Resolution Analysis with 1xTS peak marked
Rotor Bar Test (motor current)
"You suspect a rolling element bearing
Bearing/Gear - PeakVue
failure High Frequency Analysis
‘You notice that the equipment speed _| Order Tracking
varies during data collection and is
spearing the spectrum.
“You are unstre of taming speed Turning Speed Detection
‘You suspect gear problems
Bearing/Gear - PeakVue
High Resolution Analysis