OPERATING MANUAL 50Hz
ILFORD
1050 RC
PRINT DRYER FOR HIGH QUALITY BLACK AND WHITE
PRINT DRYING. FROM SERIAL NUMBER 1C5I174610
SAFETY
PRECAUTIONS
Your photographic equipment is powered by
mains electricity, and is designed to
comply vith international electrical,
safety standards, However, haste safety
Precautions must alvays be folloved when
operating electrical equipsent, including
the followings
Read end understand all instructions.
Certain internal parce of the equipment
become very hot with continuous use, Take
care to avoid burns.
Do not operate equipment that has beon
dropped or damaged, or has damaged
electrical leads. Have the equipsent
exanined by qualified personnel.
Do not allow any electrical lead to touch
hoe surfaces,
Avoid asuffing any electrical leads that
hang over the edge of working surfaces.
Enaure the leads are arranged ouch that
they cannot be pulled or tripped over
Xthis applies also to any extension leads).
Ensure extension leads are of a suitable
Surrent rating to prevent the lead
overheating.
Always unplug the equipment when ic is not
in use. Never pull plugs out by the lead.
Install the equipment on a normally dry
surface.
Do not dismantle the equipment unless you
are qualified to do so. Incorrect assenbly
can cause hazards both to yourself and to
che equipment .
Always obey local codes of practice,
particularly when installing equipment.
Do not destroy th
instructionsCONTENTS
Page
1 tntreduecton 3
2 Controls and indicators 5
2.1 "Power! Light 3
2.2 Dryer control 5
2.3. Temperature control 5
3 Installation 7
3.1. Print receive tray 7
3.2 Location 7
3.5 Blectrictey supply 7
3.4 Renoving yellow transit wedges 7
4 Drying prints 8
5 Switching off 9
Cleaning and simple repatrs 10
Cleaning the front roller assembly 19
Replacing a mains fuse 10
Replacing a roller tension spring n
Removing rear rellers/adjusting print
exit guide nu
7 Pawlet fading “4
7.1 Safety feature iM
8 — Specification v
Insert
Wall chare