4amedical’
producing health for the world
BOWIE & DICK TEST PACK REFERENCE TABLE
Before exposure _ After exposure
sucnttel Process
a
it
The colourchange has been occured on ‘i r
Althesurecetestcardumsintcarsncsour,
___wheh'veries the condone ordowe @ckTes,
Failure Failure Low Vacuum
Problems:
1) Not enough, vacuum power in the autoclave,
2) Over heated water which flows through the
vacuum pumb decreases the quality of vacuum,
3) Pressure valve or pressure switch which is not
functioning properly gives fault results.
Solutions:
4) ‘The problem in the vacuum pump should be solved.
2) The resistance of autoclave tank should be checked, = ——
3) The vacuum display in the autoclave should be checked continiously,
Alr Leakage
Problems:
{the door joint n bad conditions causes the E
autoclave to have alr eskage, E
2) There can be leak in. valves and sensors ofautocave
3)Check up, incase of leak inthe steam Dising. E
Solutions: E
4)Replacethedoorjointoftheautociavewiththenewone, = |
2}Contactingtotheauthorisedservicetomaintaintheautoclaved\\ |) _
Failure Failure __Non-condensed Gases
Problems:
Dur he condesation ot sten,srebes i oes no condense
comply
‘Ths 5 because of condons of environment and Source oft }
Tre rnronmer wins composed of notondeed ge caes
the alr ine eu of SoneaDeTxe. t
Solutions:
Yoni ot a eed ent ntti 3 |||) |
The note shoul be ested ates at 9 So that he fomoton OFS
- bees can oe prevented
2)Chece al joints incase of al leakage
Wet Steam: Overheated Steam:
The wet stoam sth steam which contains high lve of water molecules
In camparson to ary steam, wet cars fas Ioner ero
omer ce wale ine ame arity ef eestencn ries tiation | Gyericote tenn has a her energy than dry condense ica
Sone arm sans og corey sbeabeimremess | eer cre a ee ae tan conden
in ther words seam shocld Be heated See
Probieme: | Probtems:
Dineascof there ent encugh solaton in the blr orsteam ppelnest | Incase ofthe pressure of source of he steam ls very high
autocave 2)Workng temperature of jacket can be high compared to its orinal temperature
2)The ste of autoclave boter isnot adequate 3)BecoUSe ofthe Inadequate steam pipe
Vee ca be oat a csi jt rand :
tis olny kt can be were wh em est
syncs fest carieg outs ontenprsure | ee
"steam pressure canbe decreed step by sep,
2) caefl about, the temperate oct seal be the
same wth the temperate of atceve
3)thec fe danatr of tam ppl is
Tcbede ale tem of atocve a
sh for Nowing of tam
4A TIP MALZEMELERISAN. TiC.iHR.ITH.LTD. STL.