Professional Documents
Culture Documents
2007
Build the phase90. You must use matched FETs for this circuit to work. Tweaking the value of the zener diode may be
needed for some FETs. It´s recommended to use sockets for the FETs and zener diode. Also, if using FETs other than
those listed, they may need to be rotated 180 degrees, “G” marked pads must match GATE pin on the actual FETs used.
Off board wiring except for the potentiometers are not shown on the layout. Trademarks remain property of their owners.
Visit www.tonepad.com for more!
2½
500k
3002 PF
GND 150k
0.01
0.01
470k
4k7
IC 1
0.05
150k
470k
150k
10uF 1½
+ 150k Q5 56k
150k 150k
D1
10k 0.05 22k
10k 10k
15uF
1
10k
+
10k
10k
10k
10k
IC 2
IC 3
22k
0.05 09 ZEP
22k
22k
250k ½
0.05
G
Q1 Q2
D2
Q3 Q4
1M MOC.DAPENOT
0
0 ½ 1 1½ 2
Parts List
Resistors Pots Diodes
http://www.tonepad.com
1 - 3M9
Schematic
22k