Professional Documents
Culture Documents
Tasarımcı, delikler ve miller için istenilen işlevi yerine getirdikten sonra herhangi bir
geometrideki geçmeyi belirlemede özgürdür. Standartlar, ortak olarak tekrarlanan
durumların nitelikli tecrübeleri ile belirlenmiştir.
Limitler ve geçmeler için iki standart mevcuttur, birisi inch birimleri diğeri ise metrik
birimleri temellidir.
Metrik standartların kullanımında, her zaman, büyük harfler deliği, küçük harfler mili
temsil eder. Üst sapma, δu Mak. Ölçü, dmak
Temel sapma, δF
Alt sapma, δL
Üst sapma, δu
Temel sapma, δF
Temel sapma, δF
Temel sapma, δF
Uluslar arası tolerans
oranı,Δd(IT numarası) Min. Ölçü, Dmin
Mak. Ölçü, Dmak
Alt sapma, minimum limit ile ilgili temel ölçü arasındaki cebirsel farktır. Uluslar arası tölerans oranı,Δd(IT
numarası)
Temel sapma, üst ya da alt sapmadan birisidir. Temel ölçüye yakın Temel sapma, δF
olan alınır.
Temel ölçü, D(d)
Tolerans, parçanın maksimum ve minimum ölçü limitleri Alt sapma, δL
Delik bazlılar, temel delik boyutu ile ilgili geçme sistemlerini Mak. Ölçü, Dmak
Boşluklu Loose running fit: for wide commercial tolerances or allowances on external members H11/c11
geçme
Free running fit: not for use where accuracy is essential, but good for large temperature H9/d9
variations, high running speeds, or heavy journal presseres
Close running fit: for running on accurate machines and for accurate location at moderate H8/f7
speeds and journal pressures
Sliding fit: where parts are not intended to run freely, but most move and turn freely and H7/g6
locate accurately
Locational clearence fit: provides snug fit for location of stationary parts, but can be freely H7/h6
assembled and disassenbled
Ara geçme Locational transition fit: for accurate location, a compromise between clearence and H7/k6
interference
Locational transition fit: for more accurate location where greater interference is H7/n6
permissible
Sıkı geçme Locational interference fit: for parts requiring rigidity and alignment with prime accuracy of H7/p6
location but without special bore pressure requirements.
Medium drive fit: for ordinary steel parts or shrink fits on light sections, the tightest fit H7/s6
usable with cast iron
Force fit: suitable for parts that can be highly stressed or for shrink fits where the heavy H7/u6
pressing forces required are impractical.
d max d F d min d F d
Temel ölçü, D(d)
Üst sapma, δu
d max d F d max d F d
d max=d+ δF = 34+(-0.120)=33.880 mm
dmin=d+ δF- Δd=34+(-0.120)-0.160=33.720 mm