0
ICOM
SERVICE
MANUAL
DUAL BAND FM TRANSCEIVER,
IC-W2A
IC-W2E
Icom Inc.INTRODUCTION
This service manual describes the latest service information for the IC-W2A/E DUAL,
BAND FM TRANSCEIVER al the time of publication.
MODEL VERSIONNo. | VERSION | SYMBOL
- v5 | USA USA
1c-Wea #07 Australia AUS
#09 re
#02 Europe EUR
lowe #03) UK. UK
#04 Italy EUR2
DANGER
NEVER connect the transceiver to an AC outlet or to a DC power supply that uses.
more than 16 V. This will ruin the transceiver.
DO NOT expose the transceiver to rain, snow or any liquids,
DO NOT reverse the polarities of the power supply when connecing the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna
connector. This could damage the transceiver's front end,
ORDERING PARTS
Be sure to include the following four points when ordering replacement parts
1, 10-digit order numbers
2. Component part number and name
3. Equipment mode! name and unit name
4, Quantity required
-
1190003760 IC TCASTIF_—IGW2NE_LOGICUNIT 5 pieces
8810004870 Screw PHM2x2.52K ICW2AE Topcover 10 pieces.
‘Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES
Make sure a problem is intemal before disassembling the transceiver.
2, DONOT open the transceiver until the transceiver is disconnected from its power
3. DONOT force any of the variable components, Turn them slowly and smoothly,
4, DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be
used for all adjustments,
5. DO NOT keep power ON for a long time when the transceiver is defective
6. DO NOT transmit power into a signal generator or a sweep generator.
7. ALWAYS connect a 30 d8~40 dB attenuator between the transceiver and a
deviation meter or spectrum analyzer when using such test equipment.
8, READ the instructions of test equipment thoroughly before connecting equip
ment to the transceiver.
L_SECTION
SECTION
SECTION
SECTION
SECTION
SECTION
SECTION
SECTION
SECTION
SECTION
24
22
23
34
32
33
34
35
36
44
42
43
44
St
52
53
7
72
73
Te
78
76
7
78
79
7-10
mH
72
7213
714
718
a
at
9
10
TABLE OF CONTENTS
‘SPECIFICATIONS
INSIDE VIEWS . .
LOGIC UNIT
VHF RF UNIT
UHF RF UNIT
CIRCUIT DESCRIPTION
VHF RECEIVER CIRCUITS
UHF RECEIVER CIRCUITS
VHF TRANSMITTER CIRCUITS
UHF TRANSMITTER CIRCUITS
PLLCIRCUITS...
OTHER CIRCUITS
ADJUSTMENT PROCEDURES
PREPARATION BEFORE SERVICING
PLL ADJUSTMENT
RECEIVER CIRCUIT
TRANSMITTER ADJUSTMENT
MECHANICAL PARTS AND DISASSEMBLY
FRONT PARTS
CHASSIS PARTS
ACCESSORIES,
PARTS LIST ..
BOARD LAYOUT.
PTTUNIT
KEY UNIT
AF UNIT.
ACK UNIT
CONNECTOR UNIT
PRT UNIT.
LOGIC UNT
VHF RF UNIT
UNF RF UNIT
VRFAUNIT
VRFBUNIT
URF A UNIT
URF B UNIT
AF FILUNIT
Uvco UNIT
OPTIONAL UNIT
UT-63 TONE SQUELCH UNIT
VOLTAGE DIAGRAM
BLOCK DIAGRAM
2-1-2
aot
aot
4-1-6
6—1~10
71-11
m1
7
7
“7
71
11