Workshop and spare parts manual rotore actuation
IQ Range Actuators Module 20 Electronics Cover Publication number E180E.
All mechanical sizes Date of issue 11/98
. Mose 20 Electronics Cover
complete, Control Knobs, Local
(Control PCB, Plastic Window.
Enceosures,
o WaterightCENELECIFMICSA
Module 208 Local Control
PCB, Looms and Screws.
Morile 20¢ Open/Ctose Knob
(Blaci), Return Spring and
ip, Shaft.
r Mocute 200
Local Stop/Remate Knob
(ed), Fong Clip, Sat
. Mocule20€ Battery
Compartment Assembly, Cast
Cover, Batery Helder and
Loom, Batery (WT on)
fl Module 20F Battery ony
Mocule 206 Plast Window
(WT oni.
fA Moxie 20 Electronics Cover
Full details from the actuator name plate must be given when
‘enquiing about or ordering spar partsModule 20A Electronics cover complete
“The actuator may remain in
‘atu on the vave required
‘when changing cut this
module. Fit isolate actuator
ftom al electrical supplies.
Remove Electro!
Cover
Using a 6mm allen key remove
the four cap head sorews
‘securing the cover
Care must be taken in
removing this cove as there
ae electrical connections
between it andthe electronics
chaetis. Disconnect the two
cables a the chassis end
taking note of ther postions to
(ase reassembly.
Refit Replacement
Electronics Cover
Please note.
itis part of the
explosionproot certifieation
It tne new cover has been in
store for any length of time it
‘would be adisabie fo check.
the stand-by battery located
behind ts access covert the
lef of he local contos.
Using a 4mm allen key loosen
‘he four fxng serews, pl off
‘over, une battery and
replace I'necessary. When
refting battery cover ensure
that spigeie ont and '0' ng
seal are sericeatie, clean and
light greased
Battery Types
For CENELEC
Enclosure
Must ony use a Duracell
Procell MN 1604 alkaline
Date. However, some
couniies outside of the EC
which accep abasic
CENELEC enclosure may
demand a battery to su their
halon specification, iin
ub then check.
For FM-CSA-WT
Enclosures
Battery type Utraif thu cell
iste.
Locate the electronics cover
‘adjacent othe electronics
‘chassis, reconnect the two
Taoms fom the cover ont the
main POB, batter lom (3 pin)
‘nto SKT, local eantrol oom (6
pin) on to SK3, beth sted
behind the LOD indeator
thatthe Oring seals
serviceable, Locate window
over the LCD indeator Ref
the four serems and tghten
‘oun.
Recommision actuator as per
publication E170E tobe founc
at the back ofthis manual'
r
! Module 20B Local control printed circuit board
= (located in the electronics cover bet
‘The actuator may remain in-
St onthe vate IF required
‘when changing ou tis
module. Fret iotte actuator
from al eectical supplies
IF Remove Electronics
Cover
Using a 6mm allen key remove
the four cap head serews
FFF securing the cover.
Care must be taken in
removing his cove a8 there
are electrical connections
between i anc the eserone
chassis, Disconnect the wo
‘cables atthe chassis end
{aking note of thelr positions to
‘ease reassembly. Retain ths
‘cover ands screws.
a a =UhCUS
Removal and
Replacement of Local
Control PCB
Using a nm alen ay remove
‘he ising PCB anc oom
shih are uated neg re
Secor cove replace wth
‘Romnen tom tang great care
nett damage the econ
amperes onthe PCB. Fa
foam na vas found aie he
IF coverthen ensure tn
pestn oar refting cove
a =
Refit Electronics
Cover
Locate the electronics cover
Pr ajacent to the electronics
‘chassis. Reconnect the two
leoms fom the cover on tthe
main PCB battery loom (3 pin)
pe 0nt0 SKC, local cont oom (6
pin) on to SK, bth situated
behind the LCD inceato.
d control knobs)
Before refting the cover
ensure thatthe spigated jot
is clean, ity greased and
that the Fring seals
‘serceabie. cate window over
the LCD indicator, refitthe four
‘screws and tghten down,
Battery
hie the actuators dowm for
maintenance tis
recommended thats battery
be changed, this is stuated in
its own compertment tothe lft
‘ofthe pushbutons, remove the
Tour fing sravs Using a 4mm
‘len key, pl of cover.
LUnctip battery and replace with
new tem, two types ae ited
{2s original equipmert.
For CENELEC
Enclosure
Must onl use a Duracell
Procell MN 1604 aking
battery. However, some
‘ountes outside of the EC
which accept abasic
CCENELEC enclosure may
demand a battery to suit their
‘atonal specicaten ifn
out, then ene,
For FM-CSA-WT
Enclosures
Battery type Utrae ithum cel
's feted,
Recommission actuator as pet
publetion £1706 to be found
atthe back ofthis manual