Professional Documents
Culture Documents
6.4.3.3 Packet Tracer - Connect A Router To A LAN - ILM PDF
6.4.3.3 Packet Tracer - Connect A Router To A LAN - ILM PDF
Instructor Note: Red font color or gray highlights indicate text that appears in the instructor copy only.
Topology
Addressing Table
Objectives
Part 1: Display Router Information
Part 2: Configure Router Interfaces
Part 3: Verify the Configuration
© 2015 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 1 of 5
Packet Tracer - Connect a Router to a LAN
Background
In this activity, you will use various show commands to display the current state of the router. You will then
use the Addressing Table to configure router Ethernet interfaces. Finally, you will use commands to verify and
test your configurations.
Note: The routers in this activity are partially configured. Some of the configurations are not covered in this
course, but are provided to assist you in using verification commands.
Note: The serial interfaces are already configured and active. In addition, routing is configured using EIGRP.
This is done so that this activity is (1) consistent with examples shown in the chapter, (2) ready to provide
complete output from show commands when the student configures and activates the Ethernet interfaces.
© 2015 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 2 of 5
Packet Tracer - Connect a Router to a LAN
© 2015 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 3 of 5
Packet Tracer - Connect a Router to a LAN
© 2015 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 4 of 5
Packet Tracer - Connect a Router to a LAN
Step 1d 6
Step 2a 2
Step 2b 6
Step 3a 2
Step 3b 6
Part 1 Total 30
Part 2 Total 2
Part 3: Verify the Step 1a 6
Configuration
Step 1b 8
Part 3 Total 14
© 2015 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 5 of 5