—G 0404— JIS G 0404:
Steel and steel products —
General technical delivery requirements
requirements defined in this Standard, thon it ie the roquiremonts agreed for
ordering or specified in the appropriate product or material standard which shall |
apply.
Remarks: The International Standard corresponding to this Standard is as
follows:
requirements.
2__Normative references The standards listed in Attached Table 1 contain
provisions which, through reference in this Standard, constitute proyisions of this
Standard. If the indication of the year of coming into effect is given to these
referred standards, only the edition of an identified year constitutes the provisions
of this Standard but the revision and amendment made thereafter are not applie
Unless the indication of the year of coming into effect is given to these referre|
standards, the most recent edition (including amendment) of the standards shall be 7
applied.
3_Definitions For the purpose of this Standard, the following definitions for thes
main terms used in this Standard apply:
a) inspection Activities such as measuring, examining, testing, characteris
of a product or service and comparing these with specified requirements
determine conformity.
b) testing Any operation or action to determine the properties or character:
of a material or product.
c) specific inspection and testing Inspection and testing carried out, befof
delivery, according to the technical requirements of the order, on the ma
808jy whether these products comply with the requirements of the order.
jnspection representative One or more individuals who is/are either:
, the inspector(s) designated in the official regulations;
{jhe manufacturer's authorized representative(s), who is/are independent of
;) production process, acting on half of the purchaser(s);
‘@ purchaser's authorized representative,
S{'unit ‘The lot or batch of products to be accepted or rejected together, on
the basis of the tests to be carried out on sample products in accordance with
‘ue requirements of the product standard or order. (See Fig. 1.)
sample product Item (example: a sheet) selected from a test unit for ins-
pection and/or testing. (See Fig. 1.)
-p)| sample A sufficient quantity of material taken from the sample product for
thepurpose of producing one or more test pieces. (See Fig. 1).
‘Remarks: In certain cases, the sample may be the sample product itself.
h) rough specimen Part of the sample having undergone machining, followed by
|" heat treatment where appropriate, for the purpose of producing test pieces.
i (See Fig. 1.)
4) test=piece Part of the sample, with specified dimensions, brought to
required condition for submission to a given test. (See Fig. 1.)
"Remarks: In certain cases, the test piece may be the sample itself or
rough specimen.
“cast (heat) analysis A chemical analysis representative of the cast (heat)
determined by the manufacturer in accordance with his own procedures.
product analysis A chemical analysis carried out on the product.
individual results are used demonstrate that the requirements of the order
‘nd/or product standard have been satisfied. .
—809-
—G o404——G 0404~
A Test unit
+ -B_ Sample products
co” Sample oe
D_ Rough specimen
E Testpiece 1)
Fig. 1 Examples of terms defined in 3 |
4__Information to be supplied by the purchaser The information to be supplied by
the purchaser shall be as follows: a
a) The purchaser shall select the steel type, the shape of the product alld
dimensions, taking the intended processing and use into account. He may take
the manufacturer's advice in making his choice.
The order shall provide all the information necessary for describing th
product and its characteristics, and also details concerning delivery such as:
1) mass, length, area, number of pieces to be delivered;
2) the product form (it may be a number referring a drawing, for example);
—810—