dleplayed in the Output program and the Select paints window Is activated
+ Select some nodes on the wall at points where large deflection can be expected
(e.g. 60.0 10.0). The nodes bested near that specific location are feted, Select the
convenient ane by checking the ax in front oft in the lis. Close the Selact painis
‘window.
+ Cilok-on the Uplate tab to clase the Output program and go back to the input
program.
Caloulate the project,
During a Staged constuction ealeulation phase, a mulipller called TM@ssage is increased
from 0.040 1.0. This perameleris displayed on the calculation info window. As soon as
[Efstage has reached the value 1.0, the construction stage is complated and the
‘calculation phase is finished, If a Staged construction eskulation finishes while TMstage
is smaller than 1.0, the programwill gke a warning mecsage. The most likely reason for
not finishing @ construction stage ie that a fale mechanism hes accurred, but there can
be other causes as well. See the Reference Manual for more information about Staged
‘consarvetion.
24 RESULTS
‘hi adclton tothe dieplacements and the stresses in the soll, the Output program can be
tueed to view the forces in structural objects. To examine the results ofthis project, follow
these St pe:
+ Olio the final caloulation phase in the Gaeutstions wiser
(G3) ile the View esteureton results bunon on the toolbar. As a result the Output
program is started, showing the deformed mesh (scaled up) at the end ofthe
selected calculation phase, with an indication of the maximum displacement (Figure:
2A).
Fiqure 213 Deformed mesh after the thin excavation stage
+ Selzet|u| fromihe side menu deplayed as the mouse pointer ie lorated on the
Incremental displacements opticn of the Deformations menu, The pl shows oolour
shadings ofthe dieplasement increments. which Indicates the forming of 6