Professional Documents
Culture Documents
Ericsson TN Configuration 2 PDF
Ericsson TN Configuration 2 PDF
- The NPU card should be installed on the slot-7 only. This is mandatory
-The MMU can be installed on any of the remaining slots.
- If you are planning to have a 1+1 protected hop make sure that you have installed the
SMU2 and MMU2 cards as shown above. No other configuration is possible for 1+1.
Initial Commissioning for Traffic Node
1. Insert all the Cards in the Traffic Node magazine.
2. Check the DC connector and verify that you are getting appropriate voltage
with correct polarity.
3. Power-ON the system .
4. During system start-up all the 3 LED on NPU card will glow.
5. When all the 3LEDs are lit on the NPU card , press the “BR” button on
the NPU card once.
6. After 30-60 seconds you will see that the Orange LED on NPU card starts
blinking, and the Green LED is continuously ON.
7. Now connect your laptop to the NPU card Ethernet Connector with a
cross- Ethernet cable.
8. Open a Internet Explorer Browser and enter the following IP address in its
address bar : 10.0.0.1 ; press Enter.
9. The page will start loading and you will see the Traffic node setup
If you see this page, it means that you have entered the
Node Installation Mode !!!
* Traffic Routing should be strictly done after this activity only !!!!
For Traffic Routing press the Configuration Tab on the menu-bar
Once you log-in you will come to the