Professional Documents
Culture Documents
h < 180 +3.0 b < 110 +4.0 S<7 +0.7 t < 6.5 +1.5
-2.0 -1.0 -0.5
180 < h < 400 +4.0 110 < b < 210 +4.0 7 < s < 10 +1.0 6.5 < t < 10 +2.0
-2.0 -2.0 -1.0
400 < h < 700 +5.0 210 < b < 325 +4.0 10 < s < 20 +1.5 10 < t < 20 +2.5
-3.0 -4.0 -1.5
h > 700 +5.0 b > 325 +6.0 20 < s < 40 +2.0 20 < t < 30 +2.5
-5.0 -5.0 -2.0
40 < s < 60 +2.5 30 < t < 40 +2.5
-2.5
s > 60 +3.0 40 < t < 60 +3.0
-3.0
t > 60 +4.0
-4.0
Tolerances on length
The sections shall be cut to ordered lengths to tolerances of:
a) + 50 mm; or
b) + 100 mm where minimum lengths are requested.
L represents the longest useable length of the section assuming
that the ends of the section have been cut square (see figure
Fig 2. Tolerances on out-of-square and web off-centre of structural steel I and H sections