It has to check if input signal is within rule scope or not. Fail refers to out of scope and Pass refers to within the scope. Pass/Fail signal can be shown by output port of the rear panel. 1. To press[UTILITY] button then press[F2]Enter into Pass/Fail menu. 2. Setup of information source: Enter into Pass/Fail menu then press[F2] to select information source. Figure 3-9 Trigger of video row 3. Template setup: To press[F4] Enter into template setup menu (Template). To press[F2] and[F3] shown in Pass / FailInterface Schematic Template menu to set horizontal and vertical tolerance scope by multi-function knob, (namely, 1-200Pixel toward horizontal direction and 1-100Pixel toward vertical direction.) Please press F4 finally Return to Pass/Fail menu. 4. Setup of output conditions: To press[F3] to set output conditions shown in Pass/Fail menu. Rear panel of Pass / Fail output 5. To begin detection: To press[F1] to open detection status shown in Pass/Fail menu. 83