573
B. Tech. EXAMINATION, Dec. 2013
(Vth Semester (Main & Re-appear)
CE
REINFORCED CONCRETE DESIGN-I
CE-305
Time ; 3 Hours Maximum Marks : 100
Before answering the Question Paper candidates should
ensure that they have been supplied the correct and
complete Question Paper. No complaints in this regard,
will be entertained after the examination.
Note: Attempt any five questions. Any missing data
can be assumed suitably. Use of Indian
‘Standards and Scientific Calculator is allowed.
1. (a) What are the advantages of limit state method
over working stress method? Compare the
ductility of Fe 250 and Fe S00 through stress
sirain curve. Identify the Indian Standard
codes with number and year for the followings
(a) Fine and Coarse aggregate (b) Reinforcing
PTO,(b)
2
(b)
3. (@)
@)
Steel Mild steel and HYSD bars (c) Dead,
Live and Wind Loads (d) Farthquake loads (e)
Ductile Detailing of Reinforcement. 10
Discuss the differences in partial safety factors
adopted for concrete and steel under limit state
of collapse and serviceability with reasons. 10
What are the basic assumptions made to
design a structural RCC member? $
Design a two way slab 4x5m with two
adjacent edges discontinuous to carry SkN/m*
with M20 grade concrete and Fe4!5 grade of
sie] using working stress method, Show all
the reinforcement details. 15
A beam 230 * 450mm carries udl so that
maximum bending moment is100kNm and
shear force is 200KN design the shear
reinforcement as per 1$:456-2000 using
‘working stress méthod. M20 grade of concrete
and Fc250 grade of stec] have been used. 10
Show all the reinforcement details of Q 3(a).
‘The figure should clearly show the covers
24)
®
s.
BLE)
(a)
()
‘required, the length of hooks at the ends of
shear reinforcement and possible anchorage
length required at supports as per codal
requirements, The beam is a cantilever beam.
10
How docs the behavior of a long column differ
“With a short column? =
Design a circular column by working stress
method with spiral reinforcement to carry
12S0kN toad with M25 grade of conerete,
FeS00 grade of steel and 3.5m in height, 15
Show the mean and characteristic load on
probability distribution curve. Why the
structures under limit state are designed for
factored load and not for characteristic Inad?
10
A RCC 230 wide beam is to be used as
cantilever beum to carry uniformly distributed
load 20KN/m over a span of 2m, Design the
beam using M20 grade of concrete and Fed 1S
grade of steel by limit state method. 10
3 [P-T.0.