i. COACH FACTORY KAPURTHALA
MD35131 Dated: 27-12-2017
‘Sub: Issue of specification no, MDTS-086 Rev-01 Schedule of requirements of
High Prossure Laminate Shost for LHB Design Coaches,
Please find enclosed a copy of specification no. MDTS-086 Rev-01 Schedule of
requirements of High Pressure Laminate Sheet for LHB Design Coaches, for information and
necessary action at your end.
(OK Singh)
Dy CME/D-2
COM, CPLE, CWE (Fur), CMM/HSQ, CMM/TK), Dy. CMM/Fur/LHB, Dy CMM/G CMT,
Dy.CPLE-IIr,
SSE /LIB. Design
USSE rRecords
Copy for kind information to:
CDE
RCFMDTS-86
KVL
‘SPECIFICATION
Schedule of Requirements for High Pressure Laminated PAGE 1 of 3
Sheets (HPL) for LHB Derign Coaches DATE 12.12.2017
[NAME DESIGNATION _ | SIGNATURE LEVEL
| Harish Kumar SSEDev De ») yadiafi7 | Prepared
| D.K. singh Dy.CMED-It 1 reype| Agreed and
| Wt erect
Samir Lohani Approved
issue Rev. | Details of changes | Date
| RevOl [1.0 Requirements, Deterioration of visibility due to smoke (Para 16), | 12.12.2017,
Toxicity (para 18) & Heat Release Rate ( Para 19) added.
12.0 Requirements; Resistance to spread of flame ( Para 15) & Limiting
, (Oxygen Index ( Para 17) modified.
3.0 Classification of test( para 3.0) added cele
Prepared f greed By
RCFRS aes. obs Daa
SPECIFICATION
Maree ‘Schedule of Requirements for High Pressure Laminated | PAGE2 of 3
Sheets (HPL) for LHB Design Coaches
OO
10 Scope:
This specification covers general requirements and method of testing of high pressure
laminated (HPL)) sheets. The HPL sheets are to be used for interior panels used inside the
LHB design coaches. Sheet size shall generally be 1200 x2400 mm. Color shall be described
by RCF at the times of approval of prototype.
2.0. Material Requirements:
Description Value Required Test Method
ee ee ‘No Surface Defect TENSE
Flatness 60 mnvM (Max. deviation) | EN-438
3 | Tolerance on flat Thickness | +0.lmm for chest greater ENGI
) | thantrarn thick
| ++0,15mm for sheet greater
| than 2mm thick
[4 | Sirightness of edge 1 SmmvMt (Max) ENS
| 5” | Squareness of rectangular | 7.Smm/M (Max) EN-438
| finished parts
| Resistance to dry heatat | Grade 304
180°C
Dimensional Stabilityat | Less than 0.3% ENGE
20°C
Resistance to immersion in | Grade 310 4
boiling water
Resistance to Staining | Grade4to5
"| Flexural strength ‘90Mpa min.
PHT | Timpact strength Grade 2 to 4 EN@S
\Grade 4105” YEN
EN-A38
a
| Appendix-1}oF
0 | UIC 564-2 01
ase By Agreed by)
Cr