Biological Effects of the Vibe Machine on
Human DNA in-vitro
Glen Rein, Ph.D.
‘Quantum Biology Research Lab
Dix Hillls, NY
Peter Moscow, Ph.D.
Irene Mosvold F.EMA.
Holistic Consultants
Louisville, KY
Introduction:
The Vibe machine is currently being investigated for its biomedical healing
effects. The Vibe generates plasma waves since its inert gases are electrically
activated by an EM pulse. Plasma waves generated by Priore were efficacious in
treating a variety of animal diseases including cancer (Riviere, 1964). Plasma
waves were also used by Rife and reported to treat a variety of diseases as well
as to kill microorganisms in-vitro (Rife, 1953). Several commercially available
plasma generating devices are now on the market, but relatively few have been
tested using contemporary scientific methods.
Plasma waves can be considered a type of non-classical EM field (Rein, 2004),
because they have properties that can not be explained by Maxwell's equations.
Some evidence indicates that classical EM fields of the same frequency,
generated in the absence of a plasma tube, are significantly less biologically
active (Bare, 1997). Other forms of non-classical EM fields have also been
shown to be biologically active using both in-vitro and in-vivo test methods (Rein,
2001).
The Quantum Biology Research Lab utilizes in-vitro biological assays to measure
the biological effects of non-classical EM fields generated from both subtle
energy devices (Rein, 1998) and healers (Rein Laskow). Of the various methods
investigated it was discovered that DNA is particularly sensitive to non-classical
EM fields. Thus, in addition to classical EM fields (Semin, 1995), non-classic EM
fields resonate with DNA producing conformational changes (winding and
unwinding) in the secondary structure of the double-helix (Rein, 1994a, 1995,
1996).
More recently a highly-sensitive DNA rewinding assay was developed taking
dynamic measurements (every 10 seconds) after prior denaturation (separation)
of the two strands making up the DNA helix. Using the new assay method it was
demonstrated that bio-eneray from healing arts practitioners slowed down the
rate of rewinding (Rein, 2003). It was therefore of interest to determine whetherthe energy fields generated from the Vibe machine could resonate with human
DNA and have similar effects to healing arts practitioners.
Goals of this Research Project
1.Obtain scientific evidence that the Vibe can produce measurable and
reproducible biological effects on DNA using state-of-the-art scientific
methodology.
2. Compare the effects of the Vibe on DNA with those obtained using the
same assay with healing arts practitioners.
3. Compare in real-time physical measures of DNA rewinding with energetic
measures using a radionics device
The Experimental Approach
In these experiments the biological system being influenced by the EM fields
from the Vibe is purified human DNA suspended in a natural ionic environment.
Utilizing the well known fact that heat shock causes DNA strands to unwind
(Marmur, 1961), the Quantum Biology Research Lab developed a sensitive
assay which involves measuring the kinetics of rewinding following heat shock. It
is well known that heat causes unwinding of the two strands of the double-helix
(Thomas, 1995). As the DNA cools, it recovers by rewinding back into an intact
double helix (Marmur, 1961). This renaturation process of rewinding can be
monitored by measuring the absorption of UV light as a function of the cooling
temperature or increasing time (Thomas, 195). Since the absorption of light
decreases as DNA rewinds, a curve is obtained with a negative slope. The larger
the negative number of the slope, the faster the DNA rewinds. During the
rewinding process, hydrogen bonds reform to connect the two strands. Thus
DNA rewinding is directly related to the number of hydrogen bonds. Since the
quantum properties of the hydrogen bond have been previously described
(Tuckerman et al, 1977), rewinding of DNA can be considered a measure of the
quantum properties of DNA.
Experimental Methods
Three types of experiments were conducted in this study. The control
experiments were done first in the presence of ambient EM fields! but in the
absence of any man-made EM fields. Vibe experiments involved exposing DNA
to the Vibe's energy field at the very end of the heat-induced unwinding. The third
set of experiments correlated typical rewinding as measured in a
spectrophotometer with energetic measures at a distance using radionic
equipment.
The specific protocol that was followed involved making a stock solution
(0.4mg/mi) of human placental DNA (Sigma Chemical Co., St. Louis) in
deionized water. The stock solution was diluted to 0.03mg/ml in water and heat
shocked (80°C for five minutes). Immediately after heat treatment the DNA wasgently transferred to a quartz cuvette and then placed inside the
spectrophotometer. For Vibe treatment experiments, the beaker containing hot
water and DNA was placed four feet from the Vibe machine at a height
corresponding to the level of the inert gas tubes. The Vibe was switched on for
one or two 30 second cycles at the end of the 5 minute heating period. Then the
sample was immediately transferred to the spectrophotometer to begin the
rewinding measurements. Control experiments followed the same procedure in
the absence of a Vibe treatment.
A third set of experiments were done in collaboration with Peter Moscow and
Irene Mosvold. Nine aliquots (small samples) of the DNA stock solution were
transferred to 9 separate tested tubes and diluted with water as described above.
Each sample was labeled 1-9 and photographed. The samples remained in New
York and the photographs were sent to the HPC Ltd Clinic in Kentucky. The
photographs were used as a witness to energetically connect to the physical
DNA samples which were being heat shocked in NY. In addition a live telephone
line was used to connect the two experiments in real time. Peter began the
radionic measurements using the Harmonic Translator at time zero when
rewinding of the physical DNA began. In this way radionic and
spectrophotometric measurements were synchronized in real time.
For all experiments, the conformation of DNA was measured with state-of-the art
equipment using a UV-visible diode array spectrophotometer (Hewlett Packard
8451A) to quantify the amount of UV light absorbed (Thomas, 1995). Absorption
measurements were taken at 260nm every 10 seconds over the course of thirty
minutes. This rewinding curves were used for both quantitative (see below) and
qualitative analysis. Qualitative analysis was also done by obtaining pattern
information from the dynamic behavior over longer time periods.
Quantitative analysis of the data involved measuring the initial slope during the
first few minutes of rewinding. The slope in this region corresponds to the initial
recovery rate, classically used by biochemists in studying enzyme kinetics. The
slopes were calculated using IBM Excel software. The light grey irregular line in
Figure 1 is a plot of the raw absorption data collected by the spectrophotometer
as a function of time after heat shock. The solid black line is the computer
generated best-fit calculation of the slope. The slope was calculated for each
separate experiment and then compared statistically using a two sample t-test,
(assuming equal variance). For statistical analyses of this data a total of 10
control experiments, 4 Vibe experiments and 6 control experiments, were used.