3
G PROVIDES THE COMPLETE ENERGY DISTRIBUTION SOLUTIONcece
* Leader in Manufacturing Full Range and Diversified Busbar Trunking Systems
* Manufacturing Floor Space is one of the Biggest in Asia Pacific Region
* Factory with Total Quality Management System and Certified to ISO 9001:2000
* Factory Capable of Manufacture and supply BTS for Small to Very Large
Complexes and on Fast Track Basis
* Factory is Environmental Friendly|= MEGATRON™ BUSDUCT
INTRODUCTION
COMPLIANCE OF
DESIGN STANDARDS.
‘TYPES OF CONFIGURATION
SYSTEM VOLTAGES
BUSBAR CONDUCTORS,
E-COAT INSULATION
MEGATRON introduces its new complete range of Maintenance Free Epoxy
insulated busbar trunking system to meet the latest requirements of modern high rise
commercial buildings and industrial complexes. The system allows flexibility, ease of
installation and improved electrical efficiency in the distribution of low voltage
power for both commercial and industrial applications. MEGATRON busduct is
Available from 100A to 6000A rated at 10Q0VAC in a polyphase system.
MEGATRON busducts are designed in compliance with EC60439-2 : 2000,
BS54865-2 : 1990 and AS3439.2 - 1994. Busways to UL-857 standards are also
available upon request.
MEGATRON busducts are built with high conductivity copper conductors totally
enclosed in a non-ventilated metal housing to form a low-impedance busbar trunk-
ing system.
MEGATRON busducts are designed to withstand a minimum insulation voltage of
TKV at 50 oF 60 Hz frequency or dielectric voltage of 3.5KV, Higher or lower vollages
and frequency applications are also available upon request.
‘The busbars used for MEGATRON are carefully, selected to meet all electrical,
thermal and mechanical properties and are in full compliance with international
standards and requirements, Copper composition is 99.90% minimum or its conduc
tivity in excess of 99% IACS.
“The busbar insulation material used isa specially formulated E-Coat Epoxy powder
applied in a fluidized bed process and is highly stable and reliable. €-Coat Epoxy is
rnon- hygroscopic, iner, high surface tracking and is fungus resistant. Itcan withstand
temperatures above 155°C. The Epoxy insulation is bonded directly to the busbar
conductor thus eliminating any air gap between the insulation and conductor. Water
(or moisture is not able to permeate or condense under the Epoxy insulation and
each length of the coated busbar i tested by subjecting it under water and applying,
a 3.5KV voltage to it
The state-of-the-art fluidized bed coating process produces a high quality and
uniform epoxy insulation. Firstly, the busbars are blasted and cleaned by a specially
developed process. Next they are pre-heated and then dipped in the fluidized bed
Containing a specially formulated E-coat epoxy powcler. The coated busbars are then
cured at a high controlled temperature. This results in a superior 1 mm minimum
thick coating. The insulation has very high mechanical strength against thermal
shock and overload, as well asa very high short-circuit withstand capacity. Iti both
fire resistant and waterproof and has a stable polymer structure which does not
deteriorate in its mechanical, electrical and thermal properties.