\ ee P25 Laberatry anal for rca Y (een 018200
TITLE: ELECTROMANGETIC FIELD.
i
he magnetic fi
fi, Determine the value of constant, k.
Theory:
‘A magnetic field can be produced if current flow in a conductor. This can be
obtained by wrapping a wire carrying current around a nal
‘The magnetic field strength in the solenoid can be calculated by using
Biot-Savar law.
Magnetic fel strength, = HX! 1
where He = 4nx107H ability of free space )
the solenoid
L = Length of
FIGURE 1
Page 1 of 7
'5P025 Laboratory Manual or Pracical Test (Sesion 2018/2019)
So, n= kB where kis constant 12
Substitute 1.1 int 12, we obtain n= 4M 13
Apparatus:
‘An ron nail wound with 20 turs of copper wire
‘Aretot stand
Pins 30
An ammeter
‘Armeter rule
A theos
Two petri dishes
‘ADC power supply (6V)
A switch
Connecting wires -7
Procedure:
ish containing pins tothe tips ofthe nail,
ish once the pins atracted tothe nail
ish and record
Repeat steps (3) to (6) for at least five different reading of eurrents.
Note: Do not exceed 3 A of current to avoid 100 many pins
‘attracted at a time.
Page 2 of7ep SP Let Mana for Pract Tu en ssn
TITLE: RESISTIVITY
Vearning Outcomes;
A
length, J and inversely
lows:
ofthe wire.
When the length ofthe wite increases, the resistance increases
Therefore Vy = (25) 3
a
Apparatus:
A 120 em Constantan Wire
ADC Power supply (4V)
ADC Ammeter (1A)
ADC Voltmeter (SV)
A Rheos
A Switch
Connecting Wires
Micrometer screw gauge
Page 3 of 7
Procedure:
‘SPO2S Laboratory Manual for Practical Test (Session 2018/2019)
Power Supply switch, §
Constantan wire
yA P Q
Rheostat
FIGURE 1
ameter dof the wire and record your data
Calculate the cross sectional area ofthe wire using te formu
A= (£)
7
Setup the appa s shown in FIGURE 1
x
the length of the constantan wire between crocodile clip
Pand Q to 90 cm.
(Note: Do not cut the wire. Make sure thatthe voltage ofthe DC
ower supply is 4 Volt and there is no short circuit between the
wire)
Close the switch, S,
is02
Page 4of7ratory Manual jor Practical
1 Outcomes: To determine the refractive index of glass
using a concave mi
Theory:
When an object is placed at the center of curvature, O of a concave
‘mirror feal, same size and inveried image will be formed at point O as
in Figure 1.
‘When one or more gl
placed between the oj
tobe adjusted so that
same size as the object asin Figure
land ris the average thickness ofthe glass blocks, then
Page Sof?
Practical Tea (Sesion 2018
‘$P025 Laboratory Manuf.
concave lass block
vertex
‘A plasticine
‘A rubber band
4 lens tissue
‘A methylated spirit
Procedure:
1. Clean te glass blocks and concave mirror by using lens tissue and
methylated spirit, Measure and record the thickness, of each glass
block Calculate the average thickness ofthe glass block.
ior to the wooden blocks by using the
ight bulb (object) so that the light bulb is
le axis ofthe concave mirror as shown
. Attach the concave
in Figure 3.
Page 6 of 7