1N4099 THRU 1N4135 AND 1N4614 THRUIN4627 500mW LOW NOISE SILION ZENER DIODES ee VOLTAGE RANGE 1.8 to 100 Volts FEATURES DO-35 * Zener voltage 1.8 to 100V * Low noise t * Low reverse leakage Pet T MECHANICAL CHARACTERISTICS we * CASE: Hermetically sealed glass case .DO - 35. =o ‘ FINISH: All external surfaces are corrosion resistant and leads solderable. j “THERMAL RESISTANCE : 200°C/W( Typical) junction to lead at 0.375 ~ inches | from body in DO ~ 36. Metallurgically bonded DO ~ 35’ s exhibit less than 100°C/W at zero distance from body. * POLARITY: Banded end is cathode eon » WEIGHT:0.2 grams cu » MOUNTING POSITIONS: Any us MAXIMUM RATINGS g219nggon | = Junction and Storage temperatures: - 65°Cto + 200°C, ad DC Power Dissipation:500mW Power Derating:4.OmW/‘C above 50°C in DO-35 Forward Voltage @ 200mA:1.1 Volts (1N4099 — 14135) ‘Nl mensions in et @ 100mA:1.0 Volts (1N4614 — 1N4627) * ELECTRICAL CHARCTERISTICS @ 25°C i ‘aay | aman ‘ene toe" omer oy eek | Nee en te : NOTE 1 The JEDEC type rumbers shown above have a standard tolerance of = 5% (on the nominal Zener volt- ; a ig & Ri ze ‘ae 18 age. Also available in 2% and 19 tolerance, suffix C and D respectively. Vz is measured with the diode in thermal SeRssuIS equilibrium in 25°C stil air sepa Beer Beep NOTE 2 Zener impedance is derived by superimposing on ler@ 60 Hy rms a.c. current equal to 10% of Izy ( 25a» ° NOTE 3 Based upon 400mW Bre BEB bron -la T eajansiszabaa| vonssbusbote dil seesiess) maximum power dissipation at 75°C lead temperature, lowance has been made for the higher voltage associated salseepens) with operation at higher cur- L rents. calsubaubeshslessicasbs=a dees eseubsselsee\see ees aak aus eseel deassalseawesteabaule acta 3B ws et a waa | or ‘4 é canpaneszieoekuepestenutcs poseeslenpaeeesbesbeseereoceneles: PSSeeceeacRR RRS REERRRREE RRRRRS Reg sRa) E ; bs E = JEDEC Registered Data> RATINGS AND CHARACTERISTIC CURVES (1N4099 THRU 1N4135,1N4614 THRU 1N4627) Noise density(No is specified in microvolts-rms per square-root-hertz. Actual measurement is performed using a 1 KH, to 3 KHz roe bandpass filter at a constant Zener test current(I--) at 25°C ambient temperature. Np is cal- asad from RATED POWER SeseanoNmw pb 8888 3075 T0018 T75 Load temperature TC) rom body FIGURE 1 NOISE DENSITY MEASURE- RIGOR 2 ER OS Ce MENT CIRCUIT 3 8 8 8 gases ‘TYPICAL CAPACITANCE(DF) MOF 20 35 40 80 8 75 65 80 TOOTIO ZENER VOLTAGE Ve (V) FIGURE 3 CAPACITANCE VS. ZENER VOLTAGE (TYPICAL)