c \enet
us py
71
aNwy
Randolph Gear Drive
Product of Randolph Manufacturing Company
1110 North Avenue T | Lubbock, TX 79415
(806) 765-5583 | (888) 726-4327
FAX (806) 765-7735Gear Drive Selection
The Following Information Should Be Supplied When Ordexing Gear Drives:
Mode! rumber and ratio linout co output speed)
dfne the ratio a3 the 1
FPN ouput would bave 1192 RR! tput
10 of the horizontal impat RPM 9 the vertiea|cxtut APM:
Shown below are four peasibie rotations.
rmonulactured to tis configuration
Thuust requtemants, oration, horsepower requirements and aumg head shat size
EXAMPLE A 2°3 ratio gear drive oparating at 1760,
Number { is considered stendord. Untuss noted differently, the drive wit be
Numbers 2, 3 and 4 ate special rotations and ale manulactwed when specificaly requested.
Hevieontal ~ ow Horzanal ~ Cow Horizontal ~ cow
Vertical - cow Vertical - GW
‘Minimum Thrust Requirements For Stondard Bearing Avangement
NO MINIMUM DOWNTHRUST
NO MINIMUM DOWNTHRUST
NOTE: For ota
2 Send conse ecary_ Check Tee 5 for 0 down tat onal comtnation, sed sah
rings aed some axtra heavy thst bea!
Bs
Table 2 — HORSEPOWER AND THRUST BEARING RATINGS
320] #70 | 980 | 1eq| 1480] 1760] 2090] 2200]
Percent OF HP
Percent of Thrust 105) #28122) 135) 105] soo) 96 | aa
To cbtainhersapower ard trast beatngrtrgs or he speeds ted mip he hersopowar and test bearing ting ot 1760 RPM by the
petearagain Tote
* Contact Factory