Ee
ue | REVENUE METERING staNDARDS
| Doc No. Ris.030 Re
| SUBIECT | PROCUREMENT SPECIF
TRANSFORMER 69KV
[ Descriation | Potential Transformer 69KV, Minimum Oiled or
I 100% Cast Resin
| Insulation Type:
as eee
| 350 KV at full wave crest
60 HZ
Post insulator Characteristics
1. Voltage Class, KY | as
2. Color | Chocolate brown (preferred)
1813, minimum
3._Creepage Length, mm
weg es)
Overall Dimensions (mm)
bee
| Outdoor, evi Potted
| wind veiocty
| Seismic Aceleration
| tHorzonta)
Mechanical tresses: Primary terminal |
| shall withstand the forces due to
4, Horizontal and Vertical force in |
‘most unfavorable condition, | 3000
2. Greatest static and dynamic | S000
forces alowable, N pee
|_Compliance to St _|_ANSIIEEE €57.43
‘Accuracy Cass O3orbetcer
fat 25:\OCUREMENT SPECIFICATIONS FOR POTENTIAL
[TRANSFORMER 69KV
muy Burden vA
| Accuracy Range From 90% to 110%
| ve y test at factory} j____tated vattage
Number of Core
| Single Ratio (L-<} 40250v115V
| Marked Ratio 3502 a E
Rated Secondary Voltnge ay 7
Line to Gr
Rated withstand and test voltage, KV
[
| + Low frequency withstand, KV | |
Res j 140
| Impulse lightning withstand, KV | |
posse CREE aE pee ee ae AD cana
| Namepiate |i addition to the usuat technical information |
| indicated on the device nameplate, the following
| | information shal be included
|
| 2. Customer Name: Maa
| (2% @mro. Numbers i
Shall have the provisions for the installation of
ity seals on the secondary terminal be !
lssue eer
Other Requirements:
‘A. Included in the evaluation of Bid Offer
[rPe, st report thatthe produer offered is compliant to the requirement of the
‘andard IEC 6044-2 and ANSI C57.13 The type Test Report shall be from sa ee
17025-Accredited Testing Organization.
8. For acceptance of delivery
% Factory {est reports showing compliance of the delivered products to the
standards of compliance in terms of:[me _| nvm werenwe stannanos | noctio as few. 90
SUBIECT | PROCUREMENT ‘CIFICATIONS FOR POTENTIAL ‘ssue Date | Feb. 01, 2013,
| [ Thansronnten eon r as
1. Applied voltage test.
2. Induced voltage tests
3. Accuracy test
4. Polarity check
5. Winding resistance measurement foreach rato of al windings
6 Insulation resistance measurement or insulation power factor
measurement.
2, Pattial discharge measurement.