Professional Documents
Culture Documents
Qform: Day Item March 8 March 15 March 29 April 5
Qform: Day Item March 8 March 15 March 29 April 5
Technologies
The competition between students will consist of the following parts: participating students
will get a drawing of an axisymmetric part after machining and should design the hot forged
piece and die impression for the final forging and then determine the necessary technological
chain for its manufacturing and then simulate the proposed forging process. The simulation
will be performed in QForm (which is a specific purpose software) software for estimation
and verification of the developed technology.
The University will provide Training and licenses. Training will be according to the schedule
shown below. The participants have to complete at least 30 hours of training. 15 assisted and
15 independently.
Day Item
March 8th Introduction to forging process
March 15th Introduction to Qform
March 29th Advanced topic on simulation
April 5th Introduction to Olympiad
Participating students must have approved solids mechanics. In addition, they have the
compromise to complete the training and participate in the Olympiad.
División de Ingenierías Campus Irapuato Salamanca, Carretera Salamanca - Valle de Santiago Km. 3.5
+ 1.8 Comunidad de Palo Blanco Salamanca, Gto. C.P. 36885 http://www.ingenierias.ugto.mx
fimee@salamanca.ugto.mx