RESTRICTED TECHNICAL ORDER NO. 01-40NC-1
PILOT’S
FLIGHT OPERATING
INSTRUCTIONS
C-47 AIRPLANE
PUBLISHED BY AUTHORITY OF THE COMMANDING GENERAL,
ARMY AIR FORCES, BY THE HEADQUARTERS,
AIR SERVICE COMMAND, PATTERSON FIELD, FAIRFIELD, OHIO
=e NOVEMBER 1, 1942
ahaa Revived 1-20-43,RESTRICTED 7.0. No. 01-40NC-1
LIST OF REVISION PAGES ISSUED
Page Latest Revised Date
2 1-20-43
2 11.3542
OTB: & heavy Slack vertical line, tothe
Teftof the text on revised pages, indicates
the extent of the revision. This line is
omitted where mare than SOpercent of the
age is revised,
Paragraph 5.4. of Army Regulation 380-5 relative to the handling of printed
malter which has been classilled as "Restricted’ is quoted for the informa-
‘on ofall concerned,
“d, Dissemination of restricted matter. - The information contained
in restricted documents and the essential characteristics of restricted
‘material. may be given to any person known to bo inthe eorvice ofthe United
States and to persons of undoubted loyalty and discretion who are cooperating
in Government work, but will not be communicated to the public or to the
press except by authorized military public relations agencies.”
Revised 1-20-43 Ae RESTRICTED7.0, No, 01-40NC-1
Section
1 Intreduetton
1 Deseription
1, Airplane
2) Power Plant
3. Equipment
‘TABLE OF CONTENTS
9, Oil Dilution
Bae Section
1
1
1 V__ Power Plant
a
4
Side View of Complete Alzplane
‘Three Quarter Rear View of Complete Airplane
Emergency Equipment and Exits
Foe! Sysiem Diagram
uel amd Oi! Balance Charts :
Miscellaneous Equipment Stowage Points
Tiydraulic System.
Astomati Pilot Diagram
Left-Hand Side of PUot's Compartment
‘igh-Hand Side of Pilot's Compartment
Instrument and Control Panel
Electrical Control Panels
ydraulle Control Panel
Control Pedestal
Safety Lateh Operation
Correct Attitude fo Single Eagine Fight
‘Take.olf Performance Chart
‘Rated Power Ceilings Chart
raising Chart for Level Flight- Grose Weight -20,000 Pounds
raising Chart for Level Flight - Gross Weight - 2,000 Pounds
Cruising Chart for Level Fight - Gross Weight -20,000 Pounds
‘Air -Speed Correction Chart
Cruising Power Chart
(Crulsing Fuel Consumption Chart
Power Chart
‘Aio-Rich Fuel Consumption Chart
‘Salling ped Chart
Landing Performance Chart
Specttc Operating Instructions Chart
Permissible Speeds and Loai Factors Chart
20, Flight Restrictions
VI Flying Characteristics
TM General Instructions 18 VIL_ Weight Data
1, Location of Controls 18
2. Operation of Controls 19 Vil Curves
IV Pilot's Operating Instructions 40 DK Cold Weather Operation
4, Engine Starting 40
2 Warm-up 40 X_Forcod Descent of Land Planes
3. Prior to Taxying 40 at Sea (Ditching)
4, Tanying 40
5, Prior to Take-off 41 Appendix
8, Take-off 4a
17 Approach and Landing 4a 1 U.S.A. - British Glossary of
8, Stopping Engines a ‘Nomenclature
euseesartooens E
3
0
50
BL
2
58
56
3
58
50
80
61
82
as B
8
4“
a
8
9
65
™