CFD-560
SERVICE MANUAL US Model
Canadian Model
AEP Model
E Model
[Modei Name Using [ CD Section | CFD-10/101
Similar Mechanism | Tape Section |[CFS-W304
| Optical Pick-up Block Type KSM-21018AN,
[Tape Transpon Mechanism Typo [MF-560-64
SPECIFICATIONS
0 player section Cassette-corder section
system Compact ise digital audio system Recording system rack 2-channe steroo
Laser diode properties Material: GaAlAs Frequency response TYPE | (normal cassette:
Wave length: 780 nm 40-10,000 Hz
Emission duration: Continuous
Laser output: Less than 44.6 WW General
{Tra ouput is he vee meaturedat adisance Speaker Woofer 10 em dia. 9.2 ohms
‘of apou 200 mm or he bce lens cone type
surace one opal pic beck) Tweeter: 20m
Spite speed 20 rim) 0 500 ri (rpm) Inputs Mixing merophone input jack
(ow) Aina):
Error coxrecton Sony Refined Super Strategy
Sensivty 2.45 mv
Fer low impedance microphone
Outputs Headphones jack (stereo minjack)
Fr 8-32 ohms impesance
(Cress interleave Feed Solomon Code
Number of channels 2
Frequency response 20-20,000 Hz = 1 68
‘Wow ana tuter ‘Below measurable time headphones
Maximum power output 43 W +43
Radio section
Frequency range FM:87.6-107 MHz Continved next page=
AM 631-1602 KH
ia FM: 10.7 MMe
AM: 455 He
Anal FM: Telescopic aerial
AME: Bulli ferte bar ae
CD RADIO CASSETTE-CORDER
SONY.Power requirements 220-200 AC, 50 Hz
DC 12°, 8 R20 (size 0) batenes
Power consumption AC27 W
Battory ite For CD radio cassette-corder: Section Title Page
recording Tapeplaybeck COsiyback_—— SE BVICING NOTES -
TABLE OF CONTENTS
Sony SUMING) appx 11h epee. 6h x4
Sony Akaine AMT apotox 16h appx 10H agprox en «= + GENERAL sn “6
2, MECHANICAL ADJUSTMENTS a
Dimensions po 72883217 me 3. ELECTLICAL ADJUSTMENTS 7
Mass 7849s barons) aber
Svpplied accessories Mane nad (1) 4-1, 1C Pin Funetion Desription “
Remote commander (AMT-C560) (1) 42, Block Diagram : 5
Design and specications subject to change without notice. 43, Semiconductor Lead Layo 0
4-4. Printed Wiring Boards MAIN Section ose 8
Note 4-5. Schematic Diagram —MAIN Section — 2
This applance conforms with EEC Oirecive 87/908/EEC regaring 4-6, Schematic Diagram —CD Section — 25
interterence suppression 4-7. Printed Wiring Boards —CD Section see
Options! accessories 5. EXPLODED VIEWS
Sony OYNAMIC MIGROPHONE series 5-1. Rear Cabinet Blok Section snd
Sony MOR steree headohone series 5:2. Front Cabinet Block Section “3
53. CD Unit Block Section M
Set. Mechanism Block Section (1) (Deck A) 235
5-5. Mcchanism Block Section (2) (Deck A) 36
5-6 Mechanism Block Section (3) (Deck B). “-ene37
5-7. Mechanism Block Section (3) (Deck B) 38
S58, Optical Pickup Block Section 39
5:9. Speaker Block Section ve
6. ELECTRICAL PARTS LIST “1
‘Tris Compact Dise player clastad as
CLASS LASER pot.
‘To CLASS 1 LASER PRODUCT a
loemesontne toter ear.
MODEL IDENTIFICATION
Us made: Carvd on rar cabinet
Except US model: Model number abe.
SONY.
moet no. CFD-560.
CD RADIO CASSETTE-CORDER
SAFETY-RELATED COMPONENT WARNING!
‘COMPONENTS IDENTIFIED BY MARK 4 OR DOTTED
LINE WITH MARK A\ ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB:
LISHED BY SONY.
ATTENTION AU COMPOSANT AVANT RAPPORT
‘A La sécunirér
Les COMPOSANTS IDENTIFIES PAR UNE MARQUE A,
SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE
DES PIECES SONT CRITIQUES POUR LA SECURITE
DE FONCTIONNEMENT. NE REMPLACER CES COM.
POSANTS QUE PAR DES PIECES SONY DONT LES
NUMEROS SONT OONNES. DANS CE MANUEL OU
DANS LES SUPPLEMENTS PUBLIES PAR SONY.
Us model: AC: 120 60s 25,0
Ccanatian,€ mods AC: 120 6OHE 27 W
"AEP modal: AC: 20-290 ~ 6OHz 27 WSAFETY CHECK-OUT
After correcting the original service problem,
perform the following safety check before releasing
the set to the customer:
‘Check the antenna terminals, metal trim, “metallized”
knobs, screws, and all other exposed metal parts for
[AC leakage, Check leakage as described below.
LEAKAGE TEST
‘The AC leakage from any exposed metal part to
‘earth ground and from all exposed metal parts to any
‘exposed metal part having a return to chassis, must
not exceed 0.5 mA (S00 microampers), Leakage
current can be measured by any one of three
methods,
1A commercial leakage tester, such as the
Simpson 229 or RCA WT-S40A. Follow the
‘manufacturers’ instructions to use these instru
ments,
2. A battery-operated AC milliammeter. The Data
Precision 245 digital multimeter is suitable for
this job,
3, Measuring the voltage drop across a resistor by
means of a VOM of battery-operated AC volt:
meter. The “limit” indication is 0.75 V, so
analog meters must have an accurate low:
voltage scale, The Simpson 250 and Sanwa
SH-63T1d ate examples of a passive VOM that
is suitable, Nearly all battery operated digital
multimeters that have a 2 VAC range are
suitable, (See Fig, A)
To Exposed Meta!
Parson Sot
1
| | |
roa | |
ose = 1540 fotmetar
| L. iar
ae
}
| = tn crore
Fig, A. Using an AC voltmeter to check AC leakage.