Professional Documents
Culture Documents
MII 16210
INSTALLATION QUICK SHIFTER After ‘16 Issue Date
P/N 08U70-MKF-D40 CBR1000RR/RA
INSTRUCTIONS April 2017
TOOLS REQUIRED
Socket (8 and 10 mm)
Ratchet
Open-end wrench (8 and 10 mm)
Torque wrench
SCS short connector (070PZ-ZY30100)
6 mm nut 10 1.0 7
7 mm flange bolt and nut 12 1.2 9
Move.
BOLT
BOLT CLIP
EVAP COVER Protect.
(If equipped)
3. Refer to the Service Manual for the motorcycle, 5. Assemble the stroke sensor and gear change arm
remove the shift arm and rod. as shown.
GEAR CHANGE ARM
STAY 7 mm FLANGE NUT
BOLT
(Save)
BOLT
ARM
(Save) 7 mm FLANGE BOLT
NUT
(Save)
STROKE SENSOR
DUMMY CONNECTOR
(Save)
2 of 5
7. Connect the stroke sensor connector as shown. 9. Install the stroke sensor/gear change arm as shown.
• Align the punch mark on the gearshift spindle
STROKE SENSOR CONNECTOR with the slit of the gear change arm.
MOTORCYCLE’S HARNESS
BOLT
(Reuse)
SPINDLE PLATE
STROKE SENSOR/
GEAR CHANGE ARM
BOLT
(Reuse)
6 mm NUT
Tighten.
265 mm
CHANGE BAR
Tighten the nuts evenly. 6 mm NUT
Tighten.
SEL UP switch:
move to the upper side menu item.
MODE switch:
select the menu item.
Initialization failure
4 of 5
OPERATING INSTRUCTIONS
This accessory enables gear changes without clutch
operation when shifting up and down during acceleration/
deceleration. (Only when engine speed is more than
1,500 rpm on upshifting or more than idle speed on
downshifting).
• If there is a problem with the gear position display,
the shift feeling may change
• If the quick shifter does not operate normally, the
gear shift can be made by normal clutch operation.
NOTE:
• For setting the Quick Shifter sensitivity (UP LVL
or DOWN LVL), refer to the Owner’s Manual.
5 of 5