INTRODUCTION
JEEP AW-4
‘The AW-4 is a four speed, electronically controlled automatic transmission.
Running gear consists of a lock-up converteroll pump:three planetary gear
sets:clutch and brake units:hydraulle accumulators:a valve body with electric
‘Solenoids and a transmission computer unit (TCU). Cables are used for shifting
‘and throttle presaure control. A neutral safety switch permits engine starting in
Park and Neutral range only. The valve body solenoids are controled by signal
from the TCU. Signal sequence is determined by volicle speed and throttle
position. Fourth gear is an 70:1 ratio overdrive range. First second,third and
Feverse gear are conventional ranges. Third geer ratio is 1:1. A separate planetary
‘gear set provides overdrive operation in fourth gear.
We thank the Chrysler Corporation for the
illustrations and information that have
‘made this booklet possible
ROBERT D. CHERRNAY DALE ENGLAND
“TECHNICAL DIRECTOR FIELD SERVICE CONSULTANT
WAYNE COLONNA ED KRUSE
‘TECHNICAL SUPERVISOR ‘TECHNICAL CONSULTANT
PETER LUBAN JIM DIAL,
‘TECHNICAL CONSULTANT ‘TECHNICAL CONSULTANT
GREGORY LIPNICK. JERRY GOTT |
TECHNICAL CONSULTANT ‘TECHNICAL CONSULTANT
DAVID CHALKER, ARSENIO RIVERA
‘TECHNICAL CONSULTANT “TECHNICAL CONSULTANT
AUTOMATIC TRANSMISSION SERVICE GROUP
9200S, DADELAND BLVD. SUITE 720,
‘MIAMI, FLORIDA 33156
(605) 670-4161
LSJEEP AW-4
INDEX
‘Transmission System. 3
Diagnosis. 1
‘Trouble Shooting... 10
‘Transmission Service. 13
“Transmission & Torque Converter Removal 6
Transmission Overhaul... 2
‘Sub-Assembly Overhaul “
Valve Body Teardown. nm
‘Transmission Assembly.
AUTOMATIC TRANSMISSION SERVICE GROUP
19200 8, Dadeland Biv.
‘Suite 720
(MIAMI FLORIDA 33186
(205) 670-4161SERVICE INFORMATION
JEEP AW-4
GEAR SHIFT POSITIONS
"The AW-{tanumision has ix gor silver po-
sition. Park, Reverse end Neural pontine are co
‘entonl and mechanically operated Te 12,8 nD
‘anges provide acral cnlled cing
"The 12 potion proves firs aad sna get eal.
‘Tha parti provides Bt ean and third par The
Drange provides Set tough forts gear Overdrive
ford gar rangeisevalabe onl when the cif lever
{iD postion Fig
‘TRANSMISSION IDENTIFICATION
‘The tranuieion LD. plate i tached to te came
(Fig 9 The plate contain the tension serial and
‘Sedal numbers. Refer othe formation 0 this plata
hen erderiog weve pars,
‘COMPONENTS AND OPERATION
ectronle Controls
‘Tae AW4 is eectronialy contralld in th forward
gvorrangea To contol cot the TCU, vabvbndy
‘Sleold nd sensors that moat voice ped hot
{Te opening sift lever poton and bake eal pi
rev
‘The TCU detrei shit nd converter lockup ta
ing aed ensigns en the sensor. The val Day
‘elect are atvetadnatvred scoring.
"Tae TOU bara self diagnose program. Component
sod cacy malfunctions canbe dagaosed wih the
o0Z2D 0
‘ig. 2 Goar Sit Postions
‘DRE Teter. Once» malfnction i need and stared
{R'TCU wonmory iis retained even after the prblen.
acbeen cased Te cancels stored malencton sn
Sy Saconect and reconnect the “Trans” fase m he
ade provides normal sit sponds
{hd pint. The Power mede provides higher engi
‘oods and shift pointe shen extra aecleration snd
tong are ned The ft dasa activated bya
‘eh in te instrament pase
"Teese incudethe tht position str TPS,
he sped tener thn nie sity so tad he
rake pil application sith
"Tae tretlepston sensors mounted the hate
‘ay eslactroncly determine rote pecs and
‘laa thi nlrmation tothe TCU tocol ahi
‘ints aod eenvertar ac.
"These senor consis of oto and magneton the
teananiaien ott shaft and watchin een
owing aaptr Tho cna switchs activated each
tine the rtrd magnet complete one revslton
‘Sensor sgeals retransmit tothe TCU.
ate The wth signal inkage and
‘anual valve pion tothe TCU through an ater-
onneting hareeae Te switch prevents engine sar
igi al pecs ther than Pak or Nesta
Fg. 3 Tanemission tontiication