Professional Documents
Culture Documents
Pedestrian areas
Advantages 3 Bitucell
High recovery
Low distortion
Standards compliance
Description
The expansion joint filler as detailed shall be Bitucell 3 Supercast rearguard ‘S’ waterstop
supplied by Fosam Company Limited. The expansion joint
filler will have been independently tested and exceed the 4 Blinding concrete
requirements of the UK Department of Transport
Specification for Highway Works series 1000, clause 5 Proofex GPX or 12X membrane
1015.
6 Fosroc Protection Board
7 Bitucell
Page 1
Bitucell
Properties Estimating
Where used to form an expansion joint in in-situ concrete, There are no health hazards associated with Bitucell in
Bitucell shall be placed against the shuttering on the normal use.
concreting side before the pour begins. Copper nails may
be used to prevent displacement in joints in suspended Fire
slabs. Alternatively, Bitucell may be bonded to the existing
slab or previous pour using a suitable contact adhesive. Bitucell is combustible and will catch fire if exposed to flame
Care should be taken not to contaminate surfaces of the or other sources of ignition.
sealing slot with the adhesive.
Joint sealing
Technical support
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com Khamis Mushayt Tel: (07) 250 0469 Fax: (07) 250 0469
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2 FO SA/Bitucell/05/A