Professional Documents
Culture Documents
00 Introduction PDF
00 Introduction PDF
การออกแบบเครื่องจักรกล 1
Credit 4 (4-0-8)
Day-Time
Section 1 Tue, Thu (13:00-15:00 pm.) Room B3102, B3103
Section 2 Tue, Thu (13:00-15:00 pm.) Room B1215, B1210
Course description
วิชาบังคับก่อน: 530211 กลศาสตร์วัสดุ 1
ปรั ช ญาการออกแบบ คุ ณ สมบั ติ วั ส ดุ ทฤษฎี ค วามเสี ย หาย
สอบครั้งที่ 1
3 Part II: Failure presentation
4 - Deflection and stiffness
5 - Failure resulting from static loading
6
Midterm Examination
8 Part III: Design of - Fatigue failure resulting from variable loading
9 Mechanical Elements - Shafts and shaft components
10 - Gear (General)
11 - Spur and Helical gears
- Bevel and Worm gears
- Screw, Fasteners, and the design of nonpermanent joints
- Welding, Bonding, and the design of permanent joints
- Mechanical springs
Calculate the shearing stress in the pin at hinge D of
the frame shown in figure below
(Given the pin at hinge D has a diameter of 30-mm and is in
single shear)
A Transmission shaft is supported and loaded as
shown in Figure below. Construct:
The torque T diagram of the shaft
The bending-moment Mz diagram for the xy plane
The bending-moment My diagram for the xz plane