PT. ARUN teuntnon’ ce
MAIN REPORT
SOIL INVESTIGATION FOR FOUNDATION
HRSG'S PROJECT AT PLANTSITE
( BOOK!)
emmeteens Memncar eet Setter Somer fee?
PT. MEIDIATAMA INDOKONSULT
TYR Demet Rem ee Tay mY ARTE eign omen) Nd
Bane Eee1, PENDAHULUAN
a, TUJUAN PENYELIDIKAN
Tujuan penyelidikan adalah untuk
mengetahui kondisi tanah pondasi untuk
rencana perletakan pondasi HRSG’s di
plant site ~ PTA.
b, LINGKUP PEKERJAAN,
Pekerjaan yang dilakukan meliputi :
Pemboran inti 10 titik @ 20 meter
SPT pada tiap lubang bor @ 13 test
UDS pada tiap lubang bor @ 2 tube
Soil mechanic Lab. test lengkap, 20 tube
Sondir 10 titik
e. LOKASI PENYELIDIKAN
Penyelidikan dilakukan di dalam komplek
PT. Arun NGL Co - Lhok Seumawe
(Gambar 1).
Sketsa lokasi titik-titik penyelidikan di
dalam komplek PT. Arun ditampilkan
pada Gambar 2.
1, INTRODUCTION
a, The Aim of the Investigation
The investigation is aimed to know the
soil condition of the plan site of the
HRSG’s Foundation - PTA.
b. SCOPE OF WORKS
The work consists of :
Core drilling 10 sites @ 20 m of depth
SPT at each hole @ 13 tests,
Undisturbed sampling at each hole @ 2
tubes
Sondir 10 sites.
¢, LOCATION OF WORK
‘The works were located inside of the PT.
‘Arun NGL Co complex ~ Lhok Seumawe
(Figure 1).
The sketch of the investigation’s site
inside the PT. Arun NGL Co complex
shown in Figure 2.
‘Soil Investigation for Foundation HRSG’s Project at Plantsite - PTA2, HASIL PENYELIDIKAN
a. GEOLOGI
- Morfologi
Lokasi penyelidikan berada di sebelah
timur pantai Sumatera, di tepi pantai; dan
termasuk dalam —wilayah Morfologi
Dataran Pantai.
Wilayah ini memiliki kemiringan kurang
dari 5% dengan air tanah yang dangkal
dan statis,
- Litologi
Litologi yang terdapat di daerah ini
merupakan aluvial endapan pantai yang
didominasi oleh pasir lanauan dan di
beberapa kedalaman terdapat beberapa
lapisan lempung dan pasir kerikilan.
dengan ketebalan lebih dari 20 meter
(hasil pemboran).
Batuan ini bersifat agak padat hingga
padat (berdasarkan nilai SPT) tetapi
belum mengalami pembatuan sehingga
mudah terurai (terutama saat dibor).
Batuan yang mendasari endapan aluvial
ini diperkirakan Formasi Julurayeuk yang
berupa endapan sungai, terdiri atas
batupasir tuffan, lempung berlignit dan
batulumpur (Peta Geologi Regional
Lembar Lhok Seumawe, Direktorat
Geologi Bandung, 1981).
3, GEOTEKNIK
a, SONDIR
Berdasarkan uji sondir yang dilakukan
sebanyak 10 titik diketahui bahwa daya
dukung tanah dengan nilai tekanan konus
lebih dari 200 kg/cm2 sudah dicapai pada
kedalaman antara 4 hingga 8 meter.
2, INVESTIGATION RESULTS
a. GEOLOGY
- Morphology
The investigation was located at the
eastern coast of Sumatera Island, close to
the beach; and morphologically is a
Coastal Plain Zone.
The investigated area is a flat with slope
less than 5% ; its ground water is shallow
and static.
- Lithology
The lithology covering the investigated
region is Aluvium / fluviatil as coastal
deposites, dominantly silty sand with
some silty clay layers and gravelly coarse
sand which its total depth more than 20
meters (boring data).
The lithology is medium dense to dense
(SPT’s number class) but not yet
lithificated so the rocks remain to be
change as loose easily (especialy when
drilled).
The lithology beneath the the aluvium
deposite could be Julurayeuk Formation
that is consist of tuffaceous sandstone,
piety clay and mudstone (Geologic Map
of Lhok —Seumawe Quadrangle;
Directorate of Geology ~ Bandung, 1981)
3. GEOTECHNIC
a. SONDIR
Refers to the 10 numbers of the Sondir
investigation at the plant site known that
the bearing capacity of the soil which the
conus pressure 200 kg/cm? were reached
at4 to 8 meters of depth.
Soll Investigation for Foundation HRSG's Project at Plantsite - PTA