Professional Documents
Culture Documents
NOTE: When applying the SEL-411L relay in line current differential applications, relays at all terminals of a
protected line must use firmware that is compatible as shown in Table A.1.
Part Number: 0 4 1 1 L X
Firmware
Standard Current Differential and Distance 0
Element
Standard Plus Sub-cycle Distance Elements, 1
Series Compensation Logic and Traveling
Wave Fault Location*
Conformal Coat
None X
Conformal Coated Circuit Boards* 2
Power Supply
48-125 Vdc or 110-120 Vac 4
125-250 Vdc or 110-240 Vac 6
Connector Type
Screw Terminal Block X
®
Connectorized Relay* 2
Secondary Inputs
300V Phase - Neutral Maximum (Wye), 1 Amp 1
Phase
300V Phase - Neutral Maximum (Wye), 5 Amp 5
Phase
Mounting
Horizontal Rack Mount H
Horizontal Panel Mount 3
Vertical Rack Mount V
Vertical Panel Mount 4
Chassis
4U, One I/O Board 4 X X X X
5U, Up to Two I/O Boards 5 X X
6U, Up to Three I/O Boards 6
Accessories
Literature
Printed Instruction
(3) P M 4 1 1 L - K T - 0 1
Manual
Wiring Harness
Connectorized® Wiring
Harness for SEL-411L W A 0 4 2 1
Relays(5)*
* Additional Cost
(1)
Ports 5A and 5B can be configured for line current differential communication or for IEEE Precision Time Protocol (PTP). If PTP is
enabled, 87L over Ethernet will be performed on Ports C, D instead of A, B. PTP is only available on Ports A, B.
(2)
Line current differential protection requires serial line differential communication options.
(3)
This product comes standard with a CD manual. One complimentary printed instruction manual is available upon request with
each product purchased.
(4)
Ports 5A and 5C are dedicated as 100BASE-FX and Ports 5B and 5D are dedicated as 10/100BASE-T.
(5) ®
Specify Connectorized Wiring Harness WA0421 using WI-2262. The standard option (WA04210BC2A) ships in the same box as
the relay. All other options ship in a separate box.
Table A.1
Firmware Version Firmware is compatible with: