You are on page 1of 15

 

Fip

fip

HEATSHRINKABLE SHEETS
Manufacturer Statement & Product data Sheets
 
 
This Section includes the Technical data sheets, safety Data 
Sheets, and Installation Instructions.   
 
 
 

 
 

Fip
g Kits
nal Drillin
io
TBK Direct

oduc ts TBK-P
P

h i p Pr TBK
Flags -CPS
saWra
p™
CANUSA
Canu
ucts uperCase
d
-CPS

o
CANUSA
-CPS
r
CSS

CANUSA

a ted P S
CANUSA
CSS
-CPS

l
S
SA-CP

CFS
CANU

u
CSS-2

e™ n s
saTub Pre-I
EAL -CPS
SUPERS CANUSA
PLX
Canu CFS CFS

CSS
CSS-2
e™
id Sleev 10 CSC-X
Wrap INR-1
CPS
CANUSA-SEAL
SUPER

ts
n e Produc CSC

propy
l e ducts MIS
S

al o
A-CP

l y
CANUS

Super
se Pr
o ore
A-CPS

P CANUS

S-PP
GTS & Offseh™
A-CPS
CANUS
GT
P-100
A-CPS SA-CPS
CANUS CANU

GTS-P
SA-CPS
A-CPS
P ev
id Sle
CANU
CANUS

GTS-P
E Wrap
GTS-P
A-CPS
CANUS
A-CPS
CANUS
T
GTS-H s
GTS-8
0
hab Sleeve
5 Re
GTS-6
A-CPS
CANUS

eves
h Shrink Sle
Hig VE
Co ts
Produc
CA
NU

ati
SA

F GT
-C

air
/PMO
PS

ng e Rep
KLOX S-
Pipelin
CPS
CANUSA-

PMA VE s ™
CANUSA-
CPS

W d Tape
WLOX
PMO/ W rap
ra id Wrapi
Fit LRKN
i ng Snap pi Bo
d CRP
Cas
CSK) Co nd™ Melt
(CSF/ at
™ Mastic Stick
Filler

ducts HCA/H
CO
o duc ts
Pr o x y Pr
i p eline id Epo
Wate
r P AQUA-S
HIELD
Liqu
HIELD
AQUA-S

HIELD
T
HBraEd-e H Brush Grad
AQUA-S e

5 de
HBE-B9
Spray G
E
ld™
HBE-F
ra
rush G
-Shie
Aqua Spray G
rade
AQW
-FF
APD-NA-rev024 AQW Canusa is registered to ISO 9001:2008.
Product Data Sheet

CanusaWrap™
Two-piece protective bulk roll with separate closure
Canusa-CPS is a leading manufacturer of
specialty pipeline coatings which, for over
-CPS
30 years, have been used for sealing and CANUSA
corrosion protection of pipeline joints and
other substrates. Canusa high
performance products are manufactured
S
to the highest quality standards and are SA-CP
CANU
available in a number of configurations to
acking
accommodate your specific project Black B
applications.

Product Description ng
Backi
CanusaWrap™ is a wraparound sleeve Yellow
with a separate closure designed for
corrosion protection of buried and Flexibility on the Job Site Applications
exposed steel pipelines. CanusaWrap™ is
Since CanusaWrap™ is supplied in bulk
supplied in bulk rolls consisting of a
crosslinked polyolefin backing, coated
rolls, just-in-time customized lengths can Oil & Gas
be quickly cut in the field to protect any
with a protective heat activated adhesive.
pipe size. This flexibility results in reduced
Once installed, the system effectively Water Pipelines
inventories and cost savings on the job
bonds and protects steel substrates and
site. CanusaWrap™ is also available in a
common main line pipe coatings including
high shrink ratio for high profile joint
polyethylene and fusion bonded epoxy. Polypropylene
protection. Consult the High Shrink data
sheet or your Canusa representative for
Features & Benefits additional information.
Pre-Insulated Pipes
Long-Term Corrosion Protection
CanusaWrap™ provides excellent resis- Easy Field Installation
tance to cathodic disbondment resulting in CanusaWrap™ can be installed quickly Girth-Weld Joints
effective long term corrosion protection. and easily in most environments. Since no
The high performance crosslinked special taping, priming or operator Configurations
backing, in combination with a broad equipment is required, product installation
range of adhesives, can be engineered for is quick and labour costs are kept to a CanusaWrap™
regular or high stress environments. Once minimum. CanusaWrap™ and the closure
installed, CanusaWrap™ provides the seals are available in yellow with a
structural integrity of a seamless tube, and thermochromic indicator and a patented 2-Layer
provides the substrate with durable Windoweld feature which visually con-
protection against abrasion and chemical firms optimum installation.
attack. Standard Shrink

Pipe Sizes
55 - 1520 (2” - 60”)

Temperature Range
up to 80°C (176°F)

CANUSA-CPS is registered to ISO 9001:2008.


CanusaWrap™
The product selection chart shown here is intended as a guide for standard products.
Consult your Canusa representative for specific projects or unique applications.
The following are typical values based on Black, Heavy Duty (L) Sleeves.

Product Selection Guide Choose your sleeve based on Operating Temperature and Characteristics listed below.
Mastic Adhesives Hot Melt Adhesives
Celsius Fahrenheit
WLG WLC WLS WLO WLON WLNN WLA WLAS
110° 230° WTG WTC WTS WTO WTON WTNN
Pipeline
Operating 90° 194°
Temperature
Sleeve Operating Characteristics

70° 158°

50° 122°

30° 86°
-40°C -40°F -40°C -40°F

Minimum Installation Temperature °C (°F) 50 (122) 60 (140) 65 (150) 75 (167) 75 (167) 90 (195) 60 (140) 90 (195)

Resistance to Circumferential Forces fair fair good good good good v. good excl
Resistance to Soil Stress fair fair good good good good v. good excl
Resistance to Axial Pipe Movement fair fair good good good good v. good excl
Main Line Coating Compatibility PE, PP, FBE, PU, Coal tar, Bitumen, PE, PP, FBE PE, FBE PE, FBE

Typical Product Properties * For higher temperature requirements refer to Canusa GTS product line.
Adhesive

Test Standard Unit


Softening Point ASTM E28 °C (°F) 100 (212) 90 (194) 77 (171) 102 (216) 102 (216) 124 (255) 72 (162) 90 (194)
Lap Shear DIN 30 672 M N/cm2 (psi) 8 (12) 30 (44) 40 (58) 40 (58) 40 (58) 52 (75) 60 (87) 117 (170)

Specific Gravity ASTM D792 .93 .93 .93 .93 .95 .95 .93 .93
Tensile Strength ASTM D638 MPa (psi) 20 (2900) 20 (2900) 20 (2900) 24 (3480) 24 (3480) 24 (3480) 20 (2900) 24 (3480)
Elongation ASTM D638 % 600 600 600 700 700 700 600 700
Hardness ASTM D2240 Shore D 46 46 46 48 52 52 46 48
Backing

Abrasion Resistance ASTM D1044 mg 45 45 45 35 30 30 45 35


Volume Resistivity ASTM D257 ohm-cm 1017 1017 1017 1017 1018 1018 1017 1017
Dielectric Voltage Brkdwn. ASTM D149 kV/mm 27 20 20 27 20 20 20 27

Impact * DIN 30 672 class C -- pass pass pass pass pass pass pass
Indentation * DIN 30 672 class C -- pass pass pass pass pass pass pass
Peel ASTM D1000 N/cm (pli) 15 (9) 55 (31) 79 (45) 80 (46) 80 (46) 115 (66) 50 (29) 120 (70)
Peel DIN 30 672 N/cm (pli) 8 (5) 50 (29) 70 (40) 65 (37) 65 (37) 90 (51) 35 (20) 86 (50)**
Cathodic Disbondment ASTM G8 mm rad 6 6 8 8 7 7 13 11
Water Absorption ASTM D570 % 0.05 0.05 0.05 0.05 0.05 0.05 0.05 0.05
Low Temp. Flexibility ASTM D2671C °C (°F) -40 (-40) 5 (23) -20 (-4) -14 (7) -14 (7) -15 (5) -32 (-26) -28 (-18)
Sleeve

DIN Approval * DIN 30 672 class -- -- -- C30 C30 -- C50 C50


Fully Recovered T Sleeve Thickness mm (mils) 2.5 (99) 2.3 (90) -- --
Fully Recovered L Sleeve Thickness mm (mils) 3.3 (131) 2.8 (111) 3.3 (131)
* Denotes L sleeve thickness** backing elongation during peeling due to superior bond strength
How To Order:
Dimensions & Ordering Info

WLO-B 450-30 BK Bulk Roll Ordering Options


CLW-B 100-15 ZZ
Closure Seal Options
CLH-B XXX-15 BK CLS-B 100-15 ZZ
Heavy Duty Thickness (L) Regular Thickness (T)
Weldable Closure Hot Melt Closure Butyl Adhesive Closure
²Colour BK-Black, YE-Yellow ZZ-BK, WW, YE BK ZZ-BK, YE
Bulk Roll Length 15, 30 m (50, 100 ft) Bulk:15,30 m (50,100 ft) Precut: 300,450,600,900mm, (12,18,24,36”)
Sleeve / Closure Width 300, 450, 600, 900mm, (12, 18, 24, 36”) 100mm (4”) 115, 150mm (4,6”) 100mm (4”)
Bulk Roll Designation B - Bulk Roll designation B - Bulk Roll

Adhesive (thickness as supplied) 1.7 mm (65 mils)¹ 1.25 mm (50 mils)¹ W- n/a H-0.35mm (14mils) S-0.75 mm (30mils)

Backing (thickness as supplied) L - 0.9 mm (36 mils) T - 0.6 mm (25 mils) 0.65mm (27 mils) 0.6mm (32 mils) 0.8mm (32 mils)

Configuration W - Bulk Roll C - Closure Seal


1
NN has an adhesive thickness of 1.1mm (45 mils) Bulk Roll Lengths: up to 600 mm width: 30 m (100ft), above 600 mm width: 15 m (50ft)
The above represents standard ordering options Consult your Canusa representative for any unique project requirements, including pre-cut sleeves or closures.
² WTON, WLON, WTNN, WLNN are available in black only.

www.canusacps.com

Canada U.S.A./Latin America Europe/Middle East Asia/Pacific


CANUSA-CPS CANUSA-CPS CANUSA-CPS CANUSA-CPS
a division of SHAWCOR LTD. a division of SHAWCOR INC. a division of Canusa Systems Ltd. a division of SHAWCOR LTD.
25 Bethridge Road 2408 Timberloch Place Unit 3, Sterling Park #05-31, Blk 52, Frontier
Rexdale, Ontario Building C-8 Gatwick Road Ubi Avenue 3
M9W 1M7, The Woodlands, Texas Crawley, West Sussex Singapore
Canada 77380, U.S.A. England RH10 9QT 408867
Tel: +1 (416) 743-7111 Tel: +1 (281) 367-8866 Tel: +44 (1293) 541254 Tel: +65-6749-8918
Fax: +1 (416) 743-5927 Fax: +1 (281) 367-4304 Fax: +44 (1293) 541777 Fax: +65-6749-8919
Canusa warrants that the product conforms to its chemical and physical description and is appropriate for the use stated on the installation guide when used in compliance with Canusa’s written instructions. Since
many installation factors are beyond our control, the user shall determine the suitability of the products for the intended use and assume all risks and liabilities in connection therewith. Canusa’s liability is stated in
the standard terms and conditions of sale. Canusa makes no other warranty either expressed or implied. All information contained in this installation guide is to be used as a guide and is subject to change without
notice. This installation guide supersedes all previous installation guides on this product. E&OE Printed on recycled paper. Recyclable. PDS-CW-rev014
Our Submittal

PAGE 12 / 12
Field Joint View
Supplied Product View

WLO/ KLO type heat-shrinkable sleeves


Table 1: Summary of Dimensions
Unit of
Dimension Description Nominal Value
Measure
A Pipe Diameter inch Various
B Total Cutback Length mm 300
C Factory Coating -- 3LPE
D Sleeve Width mm 450
E Factory Coating Overlap mm 75
F Sleeve Length mm Various
G Closure Width (Pre-attached) mm 100
H Adhesive Thickness (“as supplied”) mm 1.65
I Backing Thickness (“as supplied”) mm 0,9

25 Bethridge Road, Toronto, Ontario, Canada M9W 1M7 Tel: (416) 743-7111 Fax: (416) 743-5927 www.canusacps.com
Product Data Sheet

Wrapid Tape™
Primerless Crosslinked Protective Tape

Canusa-CPS is a leading manufacturer


of specialty pipeline coatings which, for
over 30 years, have been used for
sealing and corrosion protection of
pipeline joints and other substrates.
Canusa high performance products are
manufactured to the highest quality
standards and are available in a number
of configurations to accommodate your
specific project applications.

Product Description
Canusa Wrapid Tape™ consists of a
crosslinked polyolefin backing, coated
with a protective, heat sensitive anti-
corrosion adhesive which effectively
bonds to steel substrates and common
pipeline coatings including polyethyl-
ene and fusion bonded epoxy. Upon Long Term Protection Applications
the application of heat, Wrapid Tape™
Wrapid Tape™ is manufactured using
shrinks down to fully encapsulate the
materials that provide high electrical Oil & Gas
protected substrate. The product is
resistivity, low water absorption and low
packaged in convenient rolls with
moisture permeability. The unique
various widths to protect and repair
pipelines, fittings, bends, elbows and
crosslinking process results in a Water Pipelines
protective backing that is much tougher
other irregular configurations.
than conventional tapes, more effec-
tively resisting abrasion and damage, Repair & Rehab
Features & Benefits and thus extending the lifetime of the
Easy Installation substrate. Wrapid Tape™ can also be
double or triple wrapped for extra Fittings
The flexibility provided by the thinner mechanical protection when required.
tape dimension allows Wrapid Tape™ to
effectively protect both conventional Bends
substrates such as circular pipe as well
as irregular transitions such as elbows
and risers. Upon the application of
Girth-Weld Joints
heat, the specially formulated adhesive
flows into all surface irregularities, Configurations
forming a protective barrier against
corrosion. Wrapid Tape™

Saves Time & Money 2-Layer


Wrapid Tape™ is quick and easy to
install. Since no special priming or Pipe Sizes
operator equipment is required,
product installation is quick and labour
costs are kept to a minimum. Unlike All Sizes
conventional cold-applied tapes,
Wrapid Tape™ does not require the use Temperature Range
of high volatile primers, further mini-
mizing costs and risks to health and up to 55°C (131°F)
safety.

CANUSA-CPS is registered to ISO 9001:2008.


The product selection chart shown here is intended as a guide for standard products.
Consult your Canusa representative for specific projects or unique applications.
Wrapid Tape™
Operating Characteristics Tape Usage Guide
Hot Melt Mastic
Nominal Pipe Recommended Length of Tape Required
Diameter Tape Width 3D Bend 5D Bend
Celsius Fahrenheit HCA HCO HCC
Pipeline
Operating 110o 230o DN inches mm inches M feet M feet
Temperature o
o
90 194 25 1 50 2 2.8 9.3 2.8 9.3
Tape Operating Characteristics

o o
70 158 40 1.5 50 2 4.0 13.2 4.6 15
50 o
120 o 50 2 50 2 5.2 17 6.2 20.3
80 3 50 2 8.5 28 10.6 34.7
30o 85o
-40°C -40°F 100 4 50 2 12.3 40 14.8 48.6

Minimum Installation Temperature °C (°F) 60 (140) 65 (149) 60 (140)


125 5 75 3 11.1 36.4 13.6 44.6
Resistance to Soil Stress good good fair 150 6 75 3 14.3 46.9 18.3 60
Main Line Coating Compatibility PE, FBE, PU Bit, CT, PU, PE, PP, FBE
200 8 100 4 16.3 53.4 20.8 68.2
250 10 100 4 23.1 75.8 30.6 100.4
300 12 100 4 30.4 99.8 40.9 134.2
Typical Product Properties
>300 >12 150 6 see formula below
Adhesive

Test Standard Unit HCA HCO HCC


Softening Point ASTM E28 °C (°F) 72 (162) 102 (216) 90 (194)
2
Lap Shear ASTM D1002 N/cm (psi) 60 (87) 40 (58) 30 (44) The above table shows the typical usage for 3D and
5D bends, assuming a line coating cutback of 150
Specific Gravity ASTM D792 0.93 0.93 0.93 mm (6") and a 50 mm (2") overlap onto the pipe
Tensile Strength ASTM D638 MPa (psi) 20 (2900) 20 (2900) 20 (2900) coating.

150mm
50mm
Backing

Elongation ASTM D638 % 600 600 600


Hardness ASTM D2240 Shore D 46 46 46 L
Abrasion Resistance ASTM D1044 mg 45 45 45

Impact ASTM G14 pass/fail pass pass pass


Material Usage Table

Peel ASTM D1000 N/cm (pli) 35 (20) 52 (30) 26 (15)


Water Absorption ASTM D570 % 0.05 0.05 0.05
Cathodic Disbondment ASTM G8 mm rad 13 6 8
For other sizes, the following formula can be used: 150mm
Dielectric Voltage Brkdwn. ASTM D149 kV/mm 27 27 27
Length of tape = x pipe diameter x L/W
Low Temp. Flexibility ASTM D2671C °C (°F) -32 (-25) 5 (23) -14 (-7)
where L=length of area to be covered, and 50mm
DIN Approval DIN 30 672 class C30/C50 – –
W= ½ of tape width (for 50% overlap)
Tape

Fully Recovered Thickness mm (mils) 1.5 (60) 1.5 (60) 1.5 (60)

How To Order: Our Submittal: 100mmx10meter Roll

HCA-B 75-15 BK Wrapid Tape™


Dimensions & Ordering Info

Colour BK-Black, YE-Yellow


Length of Roll 10m (33.3 ft) 15m (50 ft)
50, 75, 100, 150, 200, 300 mm
Width of Roll (2", 3", 4", 6", 8", 12")
Bulk Roll Designation B - Bulk Roll Designation
Adhesive (thickness as supplied) A - 0.75 mm (30 mils), O - 0.75 mm (30 mils) , C - 0.75 mm (30 mils)
Backing (thickness as supplied) C - 0.4 mm (16 mils)
Configuration H - Tape
The above represents standard ordering options. Consult your Canusa representative for any unique project requirements.

www.canusacps.com

Canada U.S.A./Latin America Europe/Middle East Asia/Pacific


CANUSA-CPS CANUSA-CPS CANUSA-CPS CANUSA-CPS
a division of SHAWCOR LTD. a division of SHAWCOR INC. a division of Canusa Systems Ltd. a division of SHAWCOR LTD.
25 Bethridge Road 2408 Timberloch Place Unit 3, Sterling Park #05-31, Blk 52, Frontier
Rexdale, Ontario Building C-8 Gatwick Road Ubi Avenue 3
M9W 1M7, The Woodlands, Texas Crawley, West Sussex Singapore
Canada 77380, U.S.A. England RH10 9QT 408867
Tel: +1 (416) 743-7111 Tel: +1 (281) 367-8866 Tel: +44 (1293) 541254 Tel: +65-6749-8918
Fax: +1 (416) 743-5927 Fax: +1 (281) 367-4304 Fax: +44 (1293) 541777 Fax: +65-6749-8919
Canusa warrants that the product conforms to its chemical and physical description and is appropriate for the use stated on the installation guide when used in compliance with Canusa’s written instructions. Since many
installation factors are beyond our control, the user shall determine the suitability of the products for the intended use and assume all risks and liabilities in connection therewith. Canusa’s liability is stated in the standard
terms and conditions of sale. Canusa makes no other warranty either expressed or implied. All information contained in this installation guide is to be used as a guide and is subject to change without notice. This installation
guide supersedes all previous installation guides on this product. E&OE
Printed on recycled paper. Recyclable. PDS-A4-WT-rev015
Installation Guide

CanusaWrap™
Two-piece protective bulk roll with separate closure

Product Description Storage & Safety Guidelines Equipment List


1 2 3
To ensure maximum performance, store
Canusa products in a dry, ventilated area. Keep
CAN

products sealed in original cartons and avoid


USA

exposure to direct sunlight, rain, snow, dust or


other adverse environmental elements. Avoid
-CP

prolonged storage at temperatures above 35°C


S

SOLVENT
(95°F) or below -20°C (-4°F). Product
installation should be done in accordance with
local health and safety regulations.
Bulk Roll Closure
CanusaWrapTM is typically shipped in bulk rolls. The These installation instructions are intended as a Propane tank, hose, torch & regulator Appropriate
adhesive is protected from contamination by an guide for standard products. Consult your Canusa tools for surface abrasion
inner liner. Closures are shipped either in bulk rolls representative for specific projects or unique Knife, roller, rags & Canusa approved solvent cleanser
or pre-cut. applications.
Digital thermometer with suitable probe
Standard safety equipment: gloves, goggles, hard hat,
etc.

Product Preparation Guidelines Surface Preparation


4 Bulk Roll Closure 5
overlap

SOLVENT
L
Corner Cuts
A <450mm Pipe O.D.
Pipe O.D.: B
A-50mm, B-25mm
Closure
<450mm (18")
Cut
Underlap

Overlap

100 mm overlap W
Sleeve
>450mm (18")
150 mm overlap
Sleeve >450mm Pipe O.D. width
A-100mm, B-50mm

As a guideline,cut the required lengths of Sleeve material (L)and Closure material (W) from the bulk roll as follows Ensure that the PE coating edges are beveled to 30°.
L = Coated Pipe circumference + overlap dimension W = Sleeve Width Clean exposed steel and adjacent pipe coating with a
solvent cleanser to remove the presence of oil,
Ensure that the sleeve and closure are not damaged or contaminated. Trim corners as shown . grease, and other contaminants.
Please see “CanusaWrapTM Sleeve Cutting Guideline” for more information on alternative cutting methods.

Surface Preparation and Pre-Heat Chart Flame Intensity & Torch Size
6 Standard Sleeves Surface Preparation Min. Pre-Heat Temp. 7
SIS Standard SSPC Standard °C (°F) Pipe O.D. Pipe O.D.
Minimum Preferred Minimum Preferred <450mm >450mm
WLG WTG St2 Sa2 SP2 SP6 50 (122) (18") (18")
WLC WTC St2 Sa2 SP2 SP6 60 (140)
Mastic

WLS WTS St2 Sa2 SP2 SP6 65 (150)


WLO WTO St2 Sa2 SP2 SP6 75 (167)
WLON WTON St2 Sa2 SP2 SP6 75 (167)
WLNN WTNN St3 Sa2½ SP3 SP10 90 (195) Use moderate flame Use moderate to high
WLA St3 Sa2½ SP3 SP10 60 (140) intensity for pre-heating flame intensity for pre-
Melt
Hot

SP10 and shrinking. heating and shrinking.


WLAS St3 Sa2½ SP3 90 (195)
Minimum Torch Size: Minimum Torch Size:
150,000 BTU/hr. 300,000 BTU/hr.

Surface Preparation Pre-Heat


8 h
9 10
idt 0mm
v e W e+5
e
Sle Sleev
m +
50m

Ensure that the pipe is dry before cleaning. Wipe clean or air blast the steel and pipe coating to Pre-heat the joint area to the minimum required
Prepare the steel joint area using the Surface remove foreign contaminants. temperature (see Surface Preparation & Pre-Heat
Preparation and Pre-Heat as a guideline. Lightly Chart). Using a temperature measuring device,
abrade the pipe coating adjacent to the cutback ensure that the correct temperature is reached on
area to a distance of 50mm (2") beyond each end the steel and at least 50mm (2") on each side of the
of the sleeve width. sleeve.

CANUSA-CPS is registered to ISO 9001:2008. Part No. 99060-022


Sleeve Installation
CanusaWrap™
11 12 10 2
13

1
2

Partially remove the release liner and gently heat Centre the sleeve over the joint so that the sleeve Wrap the sleeve loosely around the pipe, ensuring
the underlap approximately 150 mm (6") from the overlaps between the 10 and 2 o'clock positions. the appropriate overlap. Gently heat the backing of
edge. Press the underlap firmly into place and remove the the underlap and the adhesive side of the overlap.
remaining release liner. Press the overlap into place.

14 15A C E

B D F

Remove any release liners from the closure. Gently heat the closure and pat it down with a gloved hand. Repeating this procedure, move from one side to
Centre the closure on the overlapping sleeve. the other. Smooth any wrinkles by gently working them outward from the centre of the closure with a roller.
Press down firmly.

16 17 18

Pipe O.D.:
<450mm (18")
1 torch
>450mm (18")
2 torches

Using the appropriate sized torch, begin at the Continue heating from the centre toward one end Shrinking has been completed when the adhesive
centre of the sleeve and heat circumferentially of the sleeve until recovery is complete. In a begins to ooze at the sleeve edges all around the
around the pipe. Use broad strokes. If utilizing similar manner, heat and shrink the remaining side. circumference. Finish shrinking the sleeve with
two torches, operators should work on opposite long horizontal strokes over the entire surface to
sides of pipe. ensure a uniform bond.
Inspection
19 20 21
2

1
2
1

While the sleeve is still hot and soft, use a hand Continue the procedure by also firmly rolling the Visually inspect the installed sleeve for the following:
roller to gently roll the sleeve surface and push any closure with long horizontal strokes from the weld • Sleeve is in full contact with the steel joint.
trapped air up and out of the sleeve, as shown outwards. • Adhesive flows beyond both sleeve edges.
above. If necessary, reheat to roll out air. • No cracks or holes in sleeve backing.

Backfilling Guidelines
After shrinking is complete, allow the sleeve to cool for 2 hours prior to lowering and backfilling. To prevent damage to the sleeve, use selected backfill
material, (no sharp stones or large particles) otherwise an extruded polyethylene mesh or other suitable shield should be used.

www.canusacps.com

Canada U.S.A./Latin America Europe/Middle East Asia/Pacific


CANUSA-CPS CANUSA-CPS CANUSA-CPS CANUSA-CPS
a division of SHAWCOR LTD. a division of SHAWCOR INC. a division of Canusa Systems Ltd. a division of SHAWCOR LTD.
25 Bethridge Road 2408 Timberloch Place Unit 3, Sterling Park #05-31, Blk 52, Frontier
Rexdale, Ontario Building C-8 Gatwick Road Ubi Avenue 3
M9W 1M7, The Woodlands, Texas Crawley, West Sussex Singapore
Canada 77380, U.S.A. England RH10 9QT 408867
Tel: +1 (416) 743-7111 Tel: +1 (281) 367-8866 Tel: +44 (1293) 541254 Tel: +65-6749-8918
Fax: +1 (416) 743-5927 Fax: +1 (281) 367-4304 Fax: +44 (1293) 541777 Fax: +65-6749-8919
Canusa warrants that the product conforms to its chemical and physical description and is appropriate for the use stated on the installation guide when used in compliance with Canusa’s written instructions. Since many
installation factors are beyond our control, the user shall determine the suitability of the products for the intended use and assume all risks and liabilities in connection therewith. Canusa’s liability is stated in the standard
terms and conditions of sale. Canusa makes no other warranty either expressed or implied. All information contained in this installation guide is to be used as a guide and is subject to change without notice. This installation
guide supersedes all previous installation guides on this product. E&OE
Printed on recycled paper. Recyclable. IG-A4-CW-rev013
Installation Guide

Wrapid Tape™
HCA, HCO, HCC
Primer-less, Crosslinked, Corrosion Protection Tape.

Product Description Storage & Safety Guidelines Equipment List


1 2 3
To ensure maximum performance, store
Canusa products in a dry, ventilated area. Keep
products sealed in original cartons and avoid
exposure to direct sunlight, rain, snow, dust or
other adverse environmental elements. Avoid
prolonged storage at temperatures above 35°C
(95°F) or below -20°C (-4°F). Product

SOLVENT
installation should be done in accordance with
local health and safety regulations.

Canusa Wrapid Tape™ is supplied in 15 m length These installation instructions are intended as a Propane tank, hose, torch & regulator
bulk rolls, in several widths to suit the project guide for standard products. Consult your Appropriate tools for surface abrasion
diameter. Canusa representative for specific projects or Knife, roller, rags & approved solvent cleanser
unique applications. Digital thermometer with suitable probe
Standard safety equipment; gloves, goggles, hard hat, etc.

Flame Intensity & Torch Size Surface Preparation


4 5 6
Pipe O.D. Pipe O.D.
SOLVENT

<450mm >450mm 50m Taped Area m


(18") (18") m+Tape+50m

Use moderate flame Use moderate to high


intensity for pre-heating flame intensity for pre-
and shrinking. heating and shrinking.

Minimum Torch Size: Minimum Torch Size: Ensure that the PE coating edges are beveled to 30°. Ensure that the pipe is dry before cleaning. Prepare
150,000 BTU/hr. 300,000 BTU/hr. Clean exposed steel and adjacent pipe coating with a the steel joint area to a minimum of St3 /SP3. Lightly
solvent cleanser to remove the presence of oil, abrade the pipe coating adjacent to the weld area to a
grease, and other contaminants. distance of 50mm (2") beyond each end of the area
to be taped.

Pre-Heat Tape Installation


7 8 9

50mm

HCC 60°C (140°F)


HCA 60°C (140°F)
HCO 75°C (165°F)
Wipe clean or air blast the steel and pipe coating to Pre-Heat the joint area to the minimum required Starting at least 50mm (2") onto the pipe coating,
remove foreign contaminants. temperature HCA: 60°C (140°F) HCO: 75°C (165°F) begin wrapping the tape around the joint, ensuring a
HCC: 60°C (140°F). Using a temperature measuring minimum 50% spiral overlap. Ensure that the
device, ensure that the correct temperature is reached powdered tape side is placed onto the pipe. Remove
on the steel and at least 50mm (2") on each side of the any plastic release liners as the product is wrapped.
tape.

CANUSA-CPS is registered to ISO 9001:2008. Part No. 99060-016


Wrapid Tape™- HCA, HCO, HCC
10 11 12

Continue wrapping the pipe ensuring a minimum Warm the tape end and press down firmly. A hold- Using a torch, begin at the edge of the tape and heat
50% overlap. down tape can be used to secure the tape end. circumferentially around the joint, working back to
the other edge.

Inspection Backfilling Guidelines


13 14
After shrinking is complete, allow the
sleeve to cool for 2 hours prior to
lowering and backfilling. To prevent
damage to the sleeve, use selected
backfill material, (no sharp stones or
large particles). Otherwise, an extruded
polyethylene mesh or other suitable
shield should be used.

Visually inspect the taped joint for the following:


• Tape is in full contact with the joint and extends
50mm (2") onto the pipe coating.
• Adhesive flows at the tape edges.
• No cracks or holes in the tape.

Tape Usage Guide


Nominal Pipe Recommended Length of Tape Required
Diameter Tape Width 3D Bend 5D Bend
The table at left shows the typical usage for 3D and 5D bends,
DN inches mm inches m feet m feet assuming a line coating cutback of 150 mm (6") and
a 50 mm (2") overlap onto the pipe coating.
25 1 50 2 2.8 9.3 2.8 9.3
150mm
50mm

40 1.5 50 2 4.0 13.2 4.6 15


50 2 50 2 5.2 17 6.2 20.3 L
80 3 50 2 8.5 28 10.6 34.7
100 4 50 2 12.3 40 14.8 48.6
125 5 75 3 11.1 36.4 13.6 44.6
Material Usage Table

150 6 75 3 14.3 46.9 18.3 60


For other sizes, the following formula can be used: 150mm
200 8 100 4 16.3 53.4 20.8 68.2 Length of tape = x pipe diameter x L/W
250 10 100 4 23.1 75.8 30.6 100.4 where L=length of area to be covered, and 50mm
300 12 100 4 30.4 99.8 40.9 134.2 W= ½ of tape width (for 50% overlap)

>300 >12 150 6 see formula at right

www.canusacps.com

Canada U.S.A./Latin America Europe/Middle East Asia/Pacific


CANUSA-CPS CANUSA-CPS CANUSA-CPS CANUSA-CPS
a division of SHAWCOR LTD. a division of SHAWCOR INC. a division of Canusa Systems Ltd. a division of SHAWCOR LTD.
25 Bethridge Road 2408 Timberloch Place Unit 3, Sterling Park #05-31, Blk 52, Frontier
Rexdale, Ontario Building C-8 Gatwick Road Ubi Avenue 3
M9W 1M7, The Woodlands, Texas Crawley, West Sussex Singapore
Canada 77380, U.S.A. England RH10 9QT 408867
Tel: +1 (416) 743-7111 Tel: +1 (281) 367-8866 Tel: +44 (1293) 541254 Tel: +65-6749-8918
Fax: +1 (416) 743-5927 Fax: +1 (281) 367-4304 Fax: +44 (1293) 541777 Fax: +65-6749-8919
Canusa warrants that the product conforms to its chemical and physical description and is appropriate for the use stated on the installation guide when used in compliance with Canusa’s written instructions. Since many
installation factors are beyond our control, the user shall determine the suitability of the products for the intended use and assume all risks and liabilities in connection therewith. Canusa’s liability is stated in the standard
terms and conditions of sale. Canusa makes no other warranty either expressed or implied. All information contained in this installation guide is to be used as a guide and is subject to change without notice. This installation
guide supersedes all previous installation guides on this product. E&OE
Printed on recycled paper. Recyclable. IG-A4-WT-rev012
Product Data Sheet

Pipeline Repair Products


Mainline coating repair products for corrosion protection

Canusa-CPS is a leading manufacturer Repair Patch


of specialty pipeline coatings which, for Mastic Filler S
SA-CP
CANU
over 30 years, have been used for
S
SA-CP
CANU
sealing and corrosion protection of
pipeline joints and other substrates.
Canusa high performance products are
manufactured to the highest quality
standards and are available in a number
of configurations to accommodate your
specific project applications.
Melt Stick

Product Description
Canusa’s Pipeline Repair Products are
used to add corrosion protection and/or
fill voids in damaged coatings. A full line Melt Sticks (MS) Applications
of products provides the flexibility to
Melt Sticks are heat-activated adhesives
make a variety of repairs to mainline
coatings, ranging from minor coating
supplied as a rod for ease of application. Oil & Gas
They are ideal for small coating repairs
damage to holidays and exposed steel.
ranging from superficial damage to
holidays and cracks up to 10mm x Water Pipelines
Features & Benefits 10mm. Melt sticks may also be used as
All of Canusa's Pipeline Repair Products a filler material below Coating Repair
Patches. Repair & Rehab
offer flexibility of installation, exhibit
excellent adhesion to steel and are
compatible with common pipeline Configurations
Mastic Filler (MF)
coatings. These products also remain -CPS

permanently flexible and provide Mastic Filler is used to fill larger voids CANUSA
Patch
superior resistance to moisture and deep crevices in damaged coatings
infiltration, resulting in a sound corrosion prior to the application of Canusa Repair
Patches. Melt Stick
protection layer.

Note: For damage greater than 150mm Mastic Filler


The Coating Repair Patch (CRP) x 150mm, a new sleeve is recom-
CRP consists of an irradiated, cross- mended.
linked polyolefin sheet coated with a Epoxy
heat-activated adhesive. It is designed
specifically for sealing and protection of Pipe Sizes
damaged pipeline coatings up to
150mm x 150mm in size. The patch
can be installed quickly with no special All Sizes
tools required. The installed patch
provides a barrier to moisture and Temperature Range
corrosion and is resistant to abrasion
and shear forces during pipeline up to 65°C (150°F)
installation and while in-service.

CANUSA-CPS is registered to ISO 9001:2000.


Pipeline Repair Products
The product selection chart shown here is
intended as a guide for standard products.
Consult your Canusa representative for
specific projects or unique applications.

Product Selection Guide


Celsius Fahrenheit CRP0 CRPN CRP65

110° 230°
Pipeline Operating Characteristics

90° 194°

70° 158°

50° 122°

30° 86°

Pipeline Operating Temp. °C (°F) 50 (122) 60 (140) 65 (150)


Minimum Installation Temp. °C (°F) 75 (167) 80 (176) 90 (195)

Resistance to Circumferential Forces good good excellent


Resistance to Soil Stress good good excellent
Resistance to Axial Pipe Movement good good excellent

Product Properties
Adhesive

Test Standard Unit CRPO CRPN CRP65

Softening point ASTM E28 °C (°F) 102 (216) 124 (255) 94 (201)
2
Lap shear DIN 30 672 N/cm (psi) 40 (58) 52 (75) 245 (350)

Specific gravity ASTM D792 0.93 0.93 0.93

Tensile strength ASTM D638 MPa (psi) 24 (3480) 24 (3480) 24 (3480)

Elongation ASTM D638 % 700 700 700

Hardness ASTM D2240 Shore D 48 48 48


35 35 35
Backing

Abrasion resistance ASTM D1044 mg


17 17 17
Volume Resistivity ASTM D257 ohm-cm 10 10 10

Dielectric Voltage Brkdwn ASTM D149 kV/mm 27 27 27

Impact DIN 30 672 class C pass pass pass

Indentation DIN 30 672 class C pass pass pass

Peel to PE or Steel ASTM D1000 N/cm (pli) 80 (46) 115 (66) 120 (70)

Peel to PE or Steel DIN 30 672 class C50 N/cm (pli) 65 (37) 90 (51) 86 (50)

Cathodic Disbondment ASTM G8 mm rad 8 17 13


Patch

Water Absorption ASTM D570 % 0.05 0.05 0.05

Low Temp. Flexibility ASTM D2671-C °C (°F) -14 (7) -15 (5) -26 (-18)

How To Order:
CRPN - B 150-30 BK Canusa Repair Patch MS-1 10-300 Melt Stick MF-B 50-3-7.5 Mastic Filler

Colour BK-Black 3.0 m (10’)


Length 300 mm (12”) Length 7.5 m (25’)
Length of Roll 15m, 30m (50 ft, 100 ft)
15 m (50’)
Width of Roll 150 (6”) - 450 (18") Thickness 3 mm (1/8”)
Diameter 10 mm (3/8”)
Configuration B-Bulk Roll
Width 50 mm (2”)
N - 0.63 mm (25 mils) Adhesive 1- (hot melt)
Configuration B - Bulk Roll
Adhesive (thickness as supplied) 65 - 0.63 mm (25 mils)
O - 1.1 mm (45 mils) Product Designation MS - Melt Stick Product Designation MF - Mastic Filler
Backing (thickness as supplied) 0.80 mm (32 mils)
Product Designation CRP-Coating Repair Patch

www.canusacps.com

Canada U.S.A./Latin America Europe/Middle East Asia/Pacific


CANUSA-CPS CANUSA-CPS CANUSA-CPS CANUSA-CPS
a division of SHAWCOR LTD. a division of SHAWCOR INC. a division of Canusa Systems Ltd. BrederoShaw (S) Pte Ltd
25 Bethridge Road 2408 Timberloch Place Unit 3, Sterling Park 101 Thomson Road
Rexdale, Ontario Building C-8 Gatwick Road #17-01/02, United Square
M9W 1M7, The Woodlands, Texas Crawley, West Sussex Singapore
Canada 77380, U.S.A. England RH10 9QT 307591
Tel: +1 (416) 743-7111 Tel: +1 (281) 367-8866 Tel: +44 (1293) 541254 Tel +65-6732-2355
Fax: +1 (416) 743-5927 Fax: +1 (281) 367-4304 Fax: +44 (1293) 541777 Fax +65-6732-9073
Canusa warrants that the product conforms to its chemical and physical description and is appropriate for the use stated on the installation guide when used in compliance with Canusa’s written
instructions. Since many installation factors are beyond our control, the user shall determine the suitability of the products for the intended use and assume all risks and liabilities in connection therewith.
Canusa’s liability is stated in the standard terms and conditions of sale. Canusa makes no other warranty either expressed or implied. All information contained in this installation guide is to be used as a
guide and is subject to change without notice. This installation guide supersedes all previous installation guides on this product. E&OE Printed on recycled paper. Recyclable. PDS-A4-PRP-rev013
ADDITIONAL MATERIALS & ITEMS TO BE PROVIDED
BY THE CONTRACTOR

1. Dry storage facilities for all materials supplied by


Canusa-CPS following manufacturers guidelines.

2. All equipment and items related to surface


preparation (including consumables).

3. Propane fuel supply requirements.

4. Sleeve installation equipment (propane torches,


digital thermometers, rollers, etc.).

5. Disposal of empty cartons and associated waste.

6. Security and assistance with visas/work permits for


specified Canusa-CPS personnel supplied for
Training Services. All related costs associated with
the visit of Canusa technician to be covered by
contractor.

7. Holiday detection voltage equipment.

8. Standard safety equipment, including safety gloves,


glasses, boots and hard hats 
Canada
CANUSA-CPS
a division of SHAWCOR LTD.
25 Bethridge Road
Toronto, Ontario
M9W 1M7,
Canada
Tel: +1 (416) 743-7111
Fax: +1 (416) 743-5927

U.S.A./Latin America
CANUSA-CPS
a division of SHAWCOR INC.
2408 Timberloch Place
Building C-8
The Woodlands, Texas
77380, U.S.A.
Tel: +1 (281) 367-8866
Fax: +1 (281) 367-4304

Europe/Middle East
CANUSA-CPS
a division of Canusa Systems Ltd.
Unit 3, Sterling Park
Gatwick Road
Crawley, West Sussex
England RH10 9QT
Tel: +44 (1293) 541254
Fax: +44 (1293) 541777

Asia/Pacific
CANUSA-CPS
Bredero Shaw (S) Pte Ltd#
05-31, Blk 52, Frontier
Ubi Avenue 3
Singapore
408867
Tel: +65-6749-8918
Fax: +65-6749-8919

www.canusacps.com

You might also like