PHILIPPINE NATIONAL wsanao
STANDARD 1es7, 40158
Steel bars for concrete reinforcement — Specification
i ti BUREAU OF PRODUCT STANDARDS”
— ‘Member to the International Organization for Standardization (IS)
Standards and Conformance Portal: wwv.ps.dt.gov.ph
“BUREAU OF PHILIPPINE STANDARDS
igPHILIPPINE NATIONAL STANDARD PNS 49:2002
Foreword
‘This Philippine National Standard for steel bars for concrete reinforcement was developed by
the Bureau of Product Standards’ Technical Committee on Steel (BPS/TC 11) through its
‘Sub-Committee on Steel for Long Products (SC 01). It cancels and replaces PNS 49:2000
edition
In the preparation of this standard, alignment to ISO 6935-2, Steel for reinforcement of
conerete - Part 2: Ribbed bars has been considered. However, due to existing laws on the
code of practice of Structural Engineers of the Philippines and due to the geographical and
environmental conditions of the country, the Technical Committee has decided to develop its
own standard applicable to Philippine condition,
In this standard, the scope includes water-quenched/tempered process steel bars. Separate
marking is however required to differentiate this type of steel bars from the hot-rolled
process,
Size 8 mm is deleted in this standard and covered in a separate standard, PNS 211 - Rerolled
steel bars for concrete reinforcement ~ Specification. This has been done to avoid confusion
among consumers.PHILIPPINE NATIONAL STANDARD PNS 49:2002/Cor. 1:2006
‘Steel bars for concrete reinforcement — Specification
Foreword
‘This corrigendum 1 to the Philippine National Standard specification for steel bars for conerete
reinforcement was prepared by the Bureau of Product Standards’ Technical Committee on
Long Steel Products (BPS/TC 11).
‘Clause/Sub-clause Modification
Table 3
‘Nominal dimensions and unit mass Change 0.007854 g/mm’ to 0.00785 g/mm’
Explanation:
0.00785 is the universally used reference value for steel density.