Partially remove the insulation to allow access to the screws Lower the window. Remove the 2 mounting screws (A) Raise the window. Secure the window in the raised position. Use tape Remove the 4 mounting screws (B) for the window Remove the 3 screws in the mounting at the crank or motor (C) Disconnect the connector. Remove the lift mechanism If necessary, install mounting sleeves on the new lift mechanism. Tighten to: 10 Nm. Install the mechanism in the door (through the upper opening)
Apply contact grease to the connector
Connect the connector Tighten all screws by hand Tighten the screws for the lift mechanism. Tighten to: 8 Nm Slide the window down until the lugs run over the window rail Loosely tighten the screws Run the window up and down a number of times. Then tighten the 4 screw for the lift mechanism. Tighten to: 8 Nm Tighten the 2 screws for the guide rail
Tightening torques
New type of window 8 Nm .
Reinstall the insulation Reinstall the door panel. Clean the window.