FRESH WATER GENERATOR
K SERIES
INSTRUCTION MANUAL
& SASAKURA
ENGINEERING CO.,LTD.Preface
This Instruction Manual serves as a guidebook about correct use of the Fresh Water Generator.
‘The Fresh Water Generator, it must be operated by a technician only who has carefully studied and fully
‘understood the instructions in this Instruction Manual or a technician who has an experience of operating,
equipment.
Safety Precautions
Before operating, maintaining or inspecting the Fresh Water Generator, carefully study the Safety Precaution
statements given below, as well as this Instruction Manual itself to be able to use the Equipment correctly. Also,
before using the Equipment, get fully familiar with the knowledge and safety-related instructions in this manual.
After reading, safely keep this manual ata location where itis readily accessible.
About Hazard Indications
‘This Instruction Manual contains WARNING and CAUTON statements to attract the attention of the readers to
the particularly important instructions in order for them to be able to use the product safely and avoid damages to
‘the users and other people and their properties. These statements have the following symbols and meanings.
Before beginning to read this manual, fully understand the meanings of these statements
ZA WARNING This statement means that, if the product is erroneously handled without following it,
personal death or severe injury can result.
This statement means that, ithe product is erroneously handled without following it
personal injury or physical damage can result.
‘Note, however, certain [A CAUTION ftatements can imply a case where if the instructions in the statements are
disregarded, a severe consequence can result depending on the situation<>
ZA\WARNING
Instruction
(Page referred to in this manval)
1] To transfer the Fresh Water Generator, use the Titing holes on the top 33
cover as well asthe wires whose capacity is enough forthe weight
specified in the assembly outline drawing.
2 | Do not incorporate a valve or cock to the steam drain outlet line. Ifa valve 33
is incorporated into the drain outlet line, and when the Fresh Water
Generator is run with such a valve in closed position, the Fresh Water
Generator can be damaged.
A\CAUTION
Instruction
(Page referred to in this manval)
‘Make sure that the inlet of the ejector pump is filled with seawater.
10.13
‘When operating the distillate pump forthe first time, discharge the
distillate overboard for a least approximately 30 minutes
10, 13, 18
Before the ship comes close to a port, land or river mouth, stop running.
the Fresh Water Generator. The seawater in such locations can be
‘contaminated with bacteria, and bacteria can be mixed in generated
illate. Also, note that the Fresh Water Generator may malfunction when
the ship is in a dirty sea.
ny 14
Do not open the bottom blow valve (V3) to restore the almospherio
pressure in the evaporator.
Otherwise, the seawater in the heater may be blown up and damage the
deflector ete.
11, 14, 18
For leakage testing, remove the evaporator vacuum gauge or fully close
‘the main valve
24
‘Observe the instructions in the instruction manual supplied from the
cleaning agent manufacturer.
25
‘There are various cleaning agent manufacturers. Refer to their catalogs for
details.
25
For this rinsing work, do not use steam because the inside surface of the
evaporator is covered with a coating.
28
‘Handle the coating material very carefully. In the case of skin contact,
wash itaway immediately with water.
30
NEVER loosen or remove the bolts that secure the tube plate. (Otherwise,
Jeakage can occur)
32
in
To protect the coating inside the Fresh Water Generator, NEVER cause
heating on the Fresh Water Generator by welding or with an open flame.
34