Radio Shack
Service |\anual
TRS-8O°
MODEL II
MICROCOMPUTER
Catalog Numbers 26-1061/1062/1063
CUSTOM MANUFACTURED IN U.S.A. BY RADIO snack fla DIVISION OF TANDY CORPORATION |
€90L/2Z901/1901-92SECTION
NUMBER
vl
CPU CIRCUIT BOARD .
FLOPPY DISK INTERFACE ..
RS-282C CIRCUIT BOARD
TABLE OF CONTENTS
INTRODUCTION
‘System Overview
DISASSEMBLY/REASSEMBLY
Disassembly Be :
Reassembly
Technical Desoription
Video Syne Circuits.
Processor
RAM ......
Address Decoding .
Memory Map. -
IO PORT Description -
Video . :
Keyboard
Cassotte Interface .
Line Printer and Real Time Ciock
10 Bus
‘Adjustmonts and Jumper Positions
‘Model III 10 Bus Detailed Description
‘Model Il PORT Bits
CPU Module Parts List
Technical Deseription . . .
Control and Data Buffering
Non-Maskable Interrupt Logie
Drive Select Latch and Motor On Logic...
ait Sate Generation and WAFTIMOUT Logie
Clock Generation Logic - .
Disk Bus Solector Logic -
Read/Write Data Puls Shaping Logic -
Disk Bus Output Drives :
Write Precompensation and Clock Recovery Lone :
Floppy Disk Controller Chip
Adjustments and Jumper Options.
Floppy Disk Interface PC Board Parts List -
RS-232C Technical Description
Pin-Out Description .
Port and Bit Assignments
RS-232C PC Board Parts List
POWER SUPPLY
Functional Specifications
Troubleshooting
Set-Up Procedures
Visual Inspection
Start-Up
No Output
Performance Test
Power Supply Component Values.
PAGE
NUMBERTABLE OF CONTENTS (Cont‘d)
SECTION PAGE
NUMBER NUMBER,
vil VIDEO MONITOR 73
Functional Specifications 5
Service Adjustments 7
vit ILLUSTRATED PARTS CATALOG . 79
Mlustrated Parts Catalog Parts List 86
*« MINI-DISK DRIVE a1
General Description 93
Introduction 93
Important Notice 93
Physical Description . . 93
Functional Description 93
Interface Connections . 93
Physical Checkout 94
Mounting the Disk Drive. 96
Resistor Termination . . .- 96
Flat Ribbon Cable Assembly « 96
‘Theory of Operation 97
Introduction... 97
Organization of the Disk Drive <1)... a7
Functional Block Diagram Description 97
Index Pulse . 97
Write Protect... 7
Track 0 Switch . 97
Spindle Drive « 97
Positioner Control 97
Data Eloctronies 98
Data Recording 99
Data Roproduction . 99
Operation . . 101
Interface Electronics Speciticaions 101
Input Control Lines ie 101
SELECT Lines (DS1*-DS4"). 7 101
Drive Motor Enable (MOTORON) 101
Direction and Step (DIR*) (STEP*) 101
Compensated Write Data (CWD) . . 101
Write Enable (WG*) . 101
Side Select (SDSEL) . 103
Output Status... . 103
Index Pulse (IP*) 103
TRACK 08 (TRKO") 103
Write Protect (WPRT") 6.0... eee eee + 103
Read Data RD")... ee eee e eee eee 103
Maintenance . . gracias si ot co a 105
Physical Description of the PC Boards set 105
Circuit Board Test Points .......-.... : 105
Option Select . : 105
Input Line Terminations. 105
Preventive Maintenance 108
Cleaning the Head 108
Alignment and Adjustment ... . 108
Drive Motor Maintenance... . 108
Carriage Movement Check... 108
Head Radial Alignment/CE Alignment 109
Track 09 Alignment 110
Index Sector Adjustment... 10
Head Amplitude/Compliance Check m1