Professional Documents
Culture Documents
J 88 14 Iii PDF
J 88 14 Iii PDF
ELECTRONIC SCIENCE
Signature and Name of Invigilator
1. (Signature) __________________________ OMR Sheet No. : ...............................................
(Name) ____________________________ (To be filled by the Candidate)
J-88-14 1 P.T.O.
ELECTRONIC SCIENCE
Paper – III
Note : This paper contains seventy five (75) objective type questions of two (2) marks each.
All questions are compulsory.
1. A triangular pulse is given at the 7. An LVDT has the following data :
input of an integrator circuit, the input = 6.3 V, Output = 5.2 V,
output will be of the form range = ± 0.5 cm. The value of
output voltage, when it is at 0.45 cm
(A) Square wave from the centre is given by
(B) Triangular wave (A) 4.68 V (B) 0.468 V
(C) Parabolic (C) 4.68 mV (D) 46.8 mV
(D) Impulse – –
8. The Boolean expression AB + ABC
–––––––––
–
2. In an RC phase shift oscillator the + (A + B + C) simplifies to
frequency of oscillation is given by – –
0.65 0.065 (A) AB + BC (B) AB + BC
(A) RC (B) – – – –
RC (C) AB + BC (D) AB + BC
6.5 1 9. In the circuit shown below, the
(C) RC (D)
2π RC output Y1 and Y2 for the given initial
condition Y1 = Y2 = 1 and after four
3. IC LM 380 is a
(A) Voltage regulator input pulses will be
(B) Rectifier
(C) Power audio amplifier
(D) Schmitt trigger
61. Assertion (A) : TWTA is a narrow 67. Assertion (A) : Optical fibers have
broader bandwidth compared to
band device and has a helical conventional copper cables.
structure and it is used as Reason (R) : Low power LASER
amplifier and oscillator. beams are considered to be
Reason (R) : In TWT, the very powerful as compared to
electron beam travels through a high power ordinary light
slow-wave structure and speed beams.
1 68. Assertion (A) : A demultiplexer can
of electron beam is of the
10 be used as a decoder.
velocity of light. Reason (R) : A demultiplexer is
built by using AND gates only.
62. Assertion (A) : An Op-Amp is a
direct coupled high gain 69. Assertion (A) : In serial communication
amplifier. system, when the transmission of
data goes in both ways, it is called
Reason (R) : It consists of one or full-duplex system. Now if two
more differential amplifiers and micro processors are connected in
usually followed by a level full duplex mode, the amount of
translator and push pull stage. data transmitted will be double to
the amount of data in half-duplex
63. Assertion (A) : To have a high mode connection.
sensitivity, a low value of Reason (R) : When the
gauge factor is desirable. transmission of data goes in
Reason (R) : Semi-conductor one way, it is called half-
duplex system and when the
strain gauges are made up of Si data moves in both ways, it is
and Ge and show piezo- called full duplex system.
resistive effect.
Paper-III 10 J-88-14
70. Assertion (A) : In control systems, 71. One of the reasons why vacuum
steady state response in the tubes eventually fail at microwave
final requirement for frequencies in that their
calculating the efficiency of the (A) transit time becomes too short
system. (B) shunt capacitive reactance
becomes too large
Reason (R) : The transient
(C) series inductive reactance
response is also critical for the
becomes too small
determination of the steady (D) noise figure increases
state response.
72. The Multicavity Klystron
Read the paragraph and answer the (A) is not low-level amplifier
question 71 to 75 : because of noise
(B) has a high repeller voltage to
ensure a rapid transit time.
Microwave tubes are used as microwave (C) is not suitable for pulsed
amplifiers and oscillators. Three general operation
type of microwave tubes in which third (D) needs a long transit time
type tubes are important because in these through the buncher cavity to
tubes there is an interaction between an ensure current modulation
electron and an RF field is continuous. The
Travelling Wave Tube (TWT) is the prime 73. The primary of the helix in a
example of this interaction. It is an travelling wave tube is to
amplifier, whose oscillator counter part is (A) prevent the electron beam from
called Backward Wave Oscillator (BWO). spreading in the long tube
The second sub-group consists of tubes in (B) reduce the axial velocity of the
which a magnetic field ensures a constant RF field
electron beam – RF field interaction, and (C) ensure broadband operation
this is complemented by the Cross-Field (D) reduce the noise figure
Amplifier (CFA). Multicavity Klystron is 74. One of the following is unlikely to be
used as high and very high power used as a pulsed device. It is the
amplifiers in the UHF and microwave (A) TWT
ranges. The frequency range covered is (B) CFA
from about 250 MHz to over 95 GHz. The (C) BWO
reflex-Klystron is a low power microwave (D) Multicavity Klystron
oscillator. It is assumed that oscillations are
started by switching transients. For 75. Indicate the false statement. Klystron
oscillations to be maintained the transient amplifiers may use intermediate
time in the repeller space cycle is given as cavities to
3 (A) prevent the oscillations that
T = n + 4 where n is an integer, each occur in two cavity Klystrons
(B) increase the bandwidth of the
value of n is said to correspond to different
device
reflex klystron mode. Reflex Klystrons
(C) improve the power gain
with integral cavities are available in the
(D) increase the efficiency of the
frequency range 4 to 200 GHz. Klystron
J-88-14 11 Paper-III
Space For Rough Work
Paper-III 12 J-88-14