AMDT
Now
JAN.
iss)
AMDT
TAN,
1991
apr
Nov
JAN,
io
amor
Nar
JAN,
1331
AMDT
Ro
TAN
1981
apr
AS 1170.2/Amat 1/1951-01-25
STANDARDS AUSTRALIA
Amendment No 1
to
AS 1170.2—1989
‘Minimum design loads on structures
(known as the SAA Loading Code)
Part 2: Wind loads
REVISED TEXT -
‘The 1989 edition of AS 11702 is amended as follows; the amendments) should be inserted in the appropiate place
SUMMARY: This Amendment applies. the History Block, Contents and Clauses 1.1. 1.22,23.1.24,24.11,2.416, 24
246,26.25,328.926,327 352,346,368, 349, 3412,56,443, Tables 3412, 2413, 2414 3415, 262,3.8
$55, 365508), 345,599.18) 349.4 341A), 54 1B) Figures 341-1951 25, 25.90), 93d, 3
. Paragraphs Al, A2, b2.8.1, D26, E3.1, E821, E323, E527, E843, E343, £06, PAIL, PASS, Ref
Pubished on 25 January 1991
Page 1 History Block
Insert “Revised and redesignated AS 1170.2—1973', after
‘Revised and redesimaied A5 CASE3—1971
Page 3. CONTENTS
Delete ‘2.8 TEMPORARY STRUCTURES’ and substiruze the following:
‘2.8 FARM BUILDINGS AND TEMPORARY STRUCTURES..
Page 4 Clause 1.1
Second paragraph, substitute ‘AUSTROADS' for ‘National Association of Australian State Road
‘Authorities’.
Page 7 Clause 1.7
In the definition of “7, substitute *2? for *H
Page 9 Clause 2.2
Item (b}: Insert ‘The’ before ‘Buildings’.
1kem {0} Delete “For unenclosed atuched canopies, ewnings and carports, the roof slope shall not
exceed 5°"
Add new Tem (:
“(The consequences of failure of the building in
social and economic terms is not high rel
that normally associated with small b
Structures that have special post-
functions, ¢.g. hospitals and communications
buildings, all not be designed using this Section.”
Page 10 Clause 2.3.1
Delete existing definition of ‘Bs’ and substitute the following:
“By = an area reduction factor for external pressures
on roofs (see Table 2.5.4)."
Last paragraph, add the following:
“Where only one limit of basic pressure is given, it shall
be assumed that the other limit is zero.”AMDT
Now
TAN.
1)
amoT
Rov
JAN,
198)
AMDT
Net
3AN.
199)
AMDT
Nor
TAX
181
AMDT
TAN,
199)
AMDT
Net
JAN,
ist
Page 10° Clause 2.4
In the heading: Delete “(p'y’
Page 10 Clause 2.4.1.1
Delete existing ‘Note’ to the Clause.
Page 10 Tables 2.4.1.2, 2.4.1.3 and 2.4.1.4
In the titles: Insert “EXTERNAL’ before ‘BASIC
PRESSURES and delete “(p’)".
In the column headings “Basic pressure (p’), kPa’: Delete ‘(p’).
Page 11. Figure 2.4.1.1
In the bottom left-hand diagram: Delete dimension ‘B". -
In the bottom right-hand diagram: Delete dimension ‘b’ and angle ‘a’, and add the following:
*NOTE: For wind blowing end-on 10a gable roof, the windward
ro0f slope shall be taken as 270.
Page 12 Table 2.4.1.5
In the title: Delete “(p’)
In the column heading ‘Basic pressure (p'), kPa’: Delete ‘(p'Y’.
Page 12, Clause 2.4.1.6
In Items (a) and (b): Delete ‘p’
Page 12 Table 2.4.2
In the title: Delete “(p'Y'.
In the column heading ‘Baste pressure (p’), kPa’: Delete ‘(p')
Page 12. Table 2.4.3.2
Delete existing table and substitute the following:
TABLE 2.4.3.2
NET BASIC PRESSURES (p ') FOR UNENCLOSED
CANOPIES, AWNINGS, CARPORTS AND EAVES
‘Net basic pressure (p), KPa
te Upwards
he fe Dowowards
[3s
BR RS [2
BERR
BEBE
128
00
oo
oe
Page 12 Clause 2.4.3.3
Delete second paragraph and substizute che following:
“Within a distance from an edge of 0.2 times the length
of the canopy, awning, carport or eave (measured
parallel to the wall to which it is attached), the roof
cladding and its immediate supports shall also be
designed for the local net basic pressures given in
Table 2.4.3.3.AMDT
TAN,
1931
AMDT
Ror
TAN,
ist
AMDT
Nor
JAN,
1981
AMDT
Not
TAN
199)
MoT
JAN.
1991
Page 13. Table 2.4.3.3
Delete existing table and substitute the following:
TABLE 2.4.3.3
LOCAL NET BASIC PRESSURES (p') ON ROOF
‘CLADDING OF CANOPIES, ETC
et base pressure (7. KPa
Ura
tung ae | a = Doerr
it %
a
car %
<0.014, 045) 21 12
to 3 “2 .
zai] 1s i
poor, coou,| 83, 18 as
tel ts 5
Page 13 Table 2.4
For roof pitch of 30°, delete the word ‘Other’ in both places.
Page 13 Clause 2.4.5
Delete the existing text and substitute the following:
‘Freestanding walls on ground shall be designed for
net basie pressures (p') of 1.8 kPa.”
Page 13. Clause 2.4.6
Delete the first paragraph and substitute the following:
*Hoardings and signs shall be designed for net basic
pressures (p") of 1.8 kPa’.
Page 14 Figure 2.81
Move ‘Derby’ on the north-western coast to its correct location and show ‘20 latitude line on the
eastern side of the map.
Delete existing Figure and sudstitine the following:
Add the following to the title:
“(Sce Paragraph D2.5.1 of Appendix D.)’