PRODUCT DESCRIPTION
www-.nanofix.co.in
FLEXEET
Nano Compesite Polymer based Heavy Duly Waterproof Coating
Nanofix Flexeet is a modified Epoxy based Two-Component protective coating that prevents
damp patches on the Internal Walls of Building & Waterproofing of Roof, Swimming Pool,
Water Reservoir, Internal walls of Water Tank, Raft, Retaining Wall & Roof Garden.
= Waterproofing of retaining Wall and Raft of
basement and Raft
= To eliminate damp patches on Ceiling, Walls
= To eliminate damp patches appearing on the
outer surface of Water Reservoir
= Effective for Roof Garden Waterproofing
APPLICATION PROCESS
= Surface should be Dry Cleaned by removing
Loose Scales, Dirt, Dust, Grease, Oil etc. by
Wire Brush
= A mixis prepared in ratio of 1:1:1 by weight
(Part A: Part B : Fresh potable water). Part A
is added to Part B, after thoroughly mixing of
two components, slowly add water into the
mix & stir it continuously tll homogeneous
emulsion is obtained
= Apply First Coat by Brush
= After drying of First Coat for 6 to 8hrs
(Depending upon Weather Condition) apply
Second Coat by brush uniformly
= Sprinkle Sand only in case of application on
Brick & Concrete Surface
= Screed or plastering should be done after
Omics
PRODUCT DATA
Appearance/ Colours
Part A: Milky White Part B: Amber
Packaging
1 Kg, 4 Kgs, 10 Kgs, 20 Kgs
Coverage
25-30 Sq.Ft./ Ka for 2 Coats of Application
Storage Conditions
Liquid should be stored in a closed container in a
Cool, Dry Place, away trom direct sunlight.
Shelf Life:12 months from the date of manufactur
Cleantek Energy Put. Ltd. én 1S0 £001 2015 Certed Company)
8/18 Chowringhee Lane, Kokata 700 016, West Bengal, India
033 4015 9494/5 E info@nanofix coin
CONES
™ Can be used on Damp Affected Areas
and Wet Surfaces
= Can be used at any Temperature
= Applicable on a wide range of Substrates.
= High strength stone forming barrier to
stop damp patches appearing under
water pressure
FORM Viscous Liquid in Two Packs
TECHNICAL DATA
Physical Properties:
Solid content by weight 80%
Pot Life: 77°F 1 Hour
Curing Time: 77°F 24 Hours
Touch Dry: 25-30 minutes
(depending on climate humidity)
‘Second Coat: After 24 Hours
‘Substrate Quality:
Loose salt or scales should be removed
before application
Gloss (60 Degrees): 85 - 90
Pencil Hardness (ASTM D- 3363): 2H
Impact Resistance (ASTM D- 2794):
Passes 120 inch-pound direct impact.
MATERIAL HANDLING SAFETY
INFORMATION
‘The material is Non-toxic. Hands and tools can
be washed with Normal Water before it hardens,
*Bost result actioved at ambient temperature above O'C
CLEANTEK
INNOVATION FOR NATION.