2._Does the cutting plane pass along the vertical CL or the horizontal CL of the top view? 3._Does the sectional view represent the top half or the bottom half of the top view? 4._Is surface X smoother than surface Y? 5._Show the surface X roughness height rating as a decimal inch value. 6._What size is the OD before machining? 7._What is the diameter of the hole in the right side of the sectional view? 8._What is the wall thickness of the hub? 9._What is the MMC of the blind hole? 10._At what angle to the vertical centerline is the .406 hole located? 11._ Determine the dimensions for the letter A. 12._Determine the dimensions for the letter B. 13._Determine the dimensions for the letter C. 14._Determine the dimensions for the letter D. 15._Determine the dimensions for the letter E. 16._Determine the dimensions for the letter F. 17._Determine the dimensions for the letter G. 18._Determine the dimensions for the letter H. 19._Determine the dimensions for the letter I. 20._Determine the dimensions for the letter J.