Professional Documents
Culture Documents
Wiring Diagrams: 1 Edition
Wiring Diagrams: 1 Edition
Bradley Artigue
1st Edition
TABLE OF CONTENTS
1 FUSE A (1/2) FAST IDLE CIRCUIT, DIVERTER VALVE BY PASS CIRCUIT, FUEL, OIL, AND
WATER GAUGES AND INDICATORS, TACHOMETER, AND STOP LIGHTS
2 FUSE A (2/2) TURN SIGNALS, BACK UP LIGHTS, FASTEN BELTS INDICATOR AND RELAY,
E.G.R BYPASS CIRCUIT AND HANDBRAKE ON AND BRAKE FLUID LEVEL
WARNING CIRCUIT
5 FUSES G, H PARKING AND SIDE MARKER LIGHTS AND INSTRUMENT CLUSTER LIGHTS
9 COMPONENT REFERENCE
18/2
G/Y W/B
18-6 R W
LB/W
BI/R B
W/B
191 193 17 33 18 18/1
Gr/W
W/B
Gr/W G/B G/Y
128/5
1 W/B
28 1 190/2
W LB/W
LB/Y Y/B G/Y Br
W W 30
G/R W/B
G/B
W/B Gr/B
C24 C25
LB/Y Y/B G/B Gr/W Br/W
G/R W/B
G/Y
LB/Y
W/B
Br/W
W/B
W/B Gr/W
Y/B W/B W/B W/B W/B
Y/B Y/B Y/B
LB/Y G/Y G/B
61
57 56 54 59
56 51
192
G/R
G/Y G/Y
LB/Y
C22
LB/Y
93
C21
R
G/R
R
R
C49 C46
R R
98 98
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
2
2
LB
Br/W W/B
C1 C11
LB/B LB
190/2
W/B
LB/W 86 128/2
Gr/W
85
C25
LB/W LB V
LB/W LB/B 32
C32 C33 30
LB V
LB/B LB
28 1
C16
A
V
42 115
LB/W
LB/W 64 G
W/B
V/W
LB/W BI/R
50 189
76
LB/W 128/1
BI/R
Gr/W B
LB/W 194/2
R/B LB/W B
W LB/W
C39 C47
LB C48
W LB/B W LB
R
LB/W
25
W C21
LB LB/B
W
W
W LB
C49 C46
LB/B W W LB
98 98
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
B B
Gr/B
LB/r
35 37
28
31
2
3 1 4 6
W/B W/B LB
G G/B
LB/B
Y R Gr/B C37
C24 Br W/B LB/W
C35
LB
C34 G G/B
3 2 2 R Br LB/B
Y/B W/B Y W R G Gr/B
m l s o n p t
LB/R
int
44 41/1 49
42/2
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
1977 FUSE B
1 1
G/B
Gr/B G Gr
C2 C10
G/B G Gr
Gr/B
BI G/R
3 4 5 6
28
C D E F
Gr/B Gr Gr/B G
Gr/B
Gr/B
C25 Gr Br LB
Gr/B I H
C32
Gr/B Br
56 BI G/R Br Gr
46 C33
BI G/R Br Gr
d c b g
69
51
LB/R
42/I
44
Br
115
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
1977 FUSES C, D, E, F
2 2
Y/B
B Y
B
C1 C11
Y/B Y
B 6 7 B
3 28 3
Y/B Y
B/V B G H B B B
B B/V
Y/R C3 84
Y/B
Y/B Y/R
B/V
32
Y/B
W/R Y/B G/R Y/B
C37 W/R
C26 C38
161
W/R W/R W/R W/R W/R Y/R W/R
C51 W/B
W Y/B G/R
57 59 67 B Y/R
56 53 54 51 W/R
L U H
E A
R
C21
40/1
95 40 50
B
W/B
74
85
99 99
Y/B Y/R
Y/B
98/1 Y/R 98/1
Y/R Y/B
B/V B/V
Y/B
Y/R
C49 C46
Y Y
98 98
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
1977 FUSES G, H
B
16 104 14
Y
B
Y Y
V
V
B/V
15
B LB
Y
C20
B/V
32
R B
9 10
28
R/B
R LB
Gr/B LB/B 30
I L
C8
37/1
R LB
V LB Gr/B LB/B
V R B
B/V
74
B/V
Gr/B Gr/B
R/B 30 65/1
C33 V/B C37
W/B R V
LB/B LB G/B
R/B
C26 C34 B
B
C21 P/B
R/B
TO RIGHT
TO LEFT TURN
TURN SIGNAL C31 W/B
SIGNAL 79
50 128/1
R
W/B
V V
O/W W/B
126
81
44
59 B
87
W/B B
V
74
C36 V/B
LB/W R/B O/W B
V V P/B 85
B B
BI/R 87
C50 C22
P/B
194
116
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
1977 FUSES I, L
12
158
C9 5
18/4 Gr 1
30 LB/B
50 1 3 2
9
10
B P Gr Gr
2 4 3
C19 Br
R Br
Gr/B
4 B B B/V
C15
189 115 32
Gr/B
BI Gr
Br/W W/B B/V B/V B/V
B
P Br/W
B
W/B
B
128/2
28
LB/B
Br/W Br
B/V
C25 R
W/B
LB/B B
B/V
P
C28 Br LB/B
Y/B B
B
46 44
66
56
23
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch
128/
128/ 2
1 128/
5
15 30
31
32
1 Left headlight 32 Hazard warning flasher 63 Low oil pressure indicator 126 Fasten belts and remove key buzzer
2 Left front parking light 33 Water temperature gauge resistor (32 OHM) 65/1 Hazard warning indicator 128/1 Fasten belts relay
3 Left front side marker 36 Windshield wiper motor 65/2 Brake system effectiveness and hand brake ON indicator 128/2 lgnition mode relay
5 Alternator 37 Heater fan motor 65/3 Fasten belts indicator 128/5 Diverter valve by-pass relay
9 Distributor 37/1 Engine fan motor 66 Battery charge indicator 158 Idle stop solenoid
10 Coil 40 Instruments lights rheostat switch 67 Parking light indicator 161 ldeogram light
12 Starter motor 40/1 ldeogram lighting potentiometer 69 High beam indicator 189 Seat belt warning delay switch
14 Horn 41/1 Windshield wiper 2-speed switch 74 Cigarette lighter 190 Fast idle electrovalve
15 Horn relay 42 Turn signal switch 76 Hand brake ON switch 190/1 Diverter valve by-pass control valve
17 Engine water temperature gauge sending unit 42/1 Highllow beam changeover switch 79 Horn button 190/2 EGR by-pass electrovalve
18 Oil pressure gauge sending unit 42/2 Windshield wiperlwasher switch 81 Current receptacle 191 Button switch on clutch for fast idle
18/1 Low oil pressure indicator sending unit 44 lgnition switch 84 Washer pump motor 192 Button switch on transmission for fast idle
18/2 Engine water temperature gauge thermostatic switch 46 Outer lighting switch 85 Courtesy light with switch 193 Fast idle system pushbutton switch
18/4 Thermostatic switch for ignition mode relay 49 Heater fan switch 87 Courtesy light jamb switch 194 Button switch on driver's seat belt
18/5 Brake fluid level switch 50 Hazard warning signal switch with light 93 Fuel tank sending unit 194/2 Gear engaged button switch
18/6 Thermostatic switch for diverter valve by-pass system 51 Speedometer 95 Trunk light
23 Battery 53 Oil pressure gauge 98 Tail, turn signal, stop and back-up lights unit
24 Back-up lights and 5th gear switch 54 Water temperature gauge 98/1 Rear side marker lights
26 Stop lights switch 56 Tachometer 99 License plate light
28 Fuse box 57 Fuel gauge 104 Thermostatic switch for engine cooling fan
28/1 Fuse, 25A 59 Clock 115 Radio connection
30 Turn signal flasher 61 Fuel reserve indicator 116 Power antenna motor
31 Windshield wiper intermittent switch 123 Power antenna switch