Professional Documents
Culture Documents
Aci 318-14 Wall-001 PDF
Aci 318-14 Wall-001 PDF
EXAMPLE DESCRIPTION
The Demand/Capacity ratio for a given axial loading and moment is tested in this
example.
RESULTS COMPARISON
Independent results are hand calculated and compared with ETABS design
check.
Percent
Output Parameter ETABS Independent Difference
CONCLUSION
The ETABS results show an acceptable match with the independent results.
HAND CALCULATION
Pn = Cc + Cs − T
where
= =
Cc 0.85 fc′ab 0.85=
• 4 •12a 40.8a
Cs =A1′ ( fs1 − 0.85 fc′) + A2′ ( fs 2 − 0.85 fc′) + A3′ ( fs 3 − 0.85 fc′)
T = As4 f s4 + As5 f s5
Pn1 =40.8a + A1′ ( fs1 − 0.85 fc′) + A2′ ( fs 2 − 0.85 fc′) A1′ ( fs1 − 0.85 fc′) +
(Eqn. 1)
A3′ ( fs 3 − 0.85 fc′) − As 4 fs 4 − As 5 fs 5
1 a
=
Pn 2 Cc d − + Cs1 ( d − d ′ ) + Cs 2 ( 3s ) − Cs 3 ( 2s ) − Ts 4 ( s ) (Eqn. 2)
e′ 2
5) Assuming the extreme fiber strain equals 0.003 and c= 30.1 inch, the steel stresses
and strains can be calculated. When the bar strain exceeds the yield strain, then
fs = f y :
c−d '
ε s1 = 0.003 ε s E ≤ Fy ; f s1 = 60.00 ksi
= 0.0028; f s =
c
c−s−d '
εs 2 = 0.003 = 0.0014 f s 2 = 40.75 ksi
c
d − c − 2s
=εs3 εs5 = 0.0000 f s 3 = 00.29 ksi
d −c
d −c−s
=εs 4 εs5 = 0.0014 f s 4 = 40.20 ksi
d −c
d −c
εs5 = 87 = 0.0028 f s 5 = 60.00 ksi
c
Substituting in Eqn. 1 and 2 and iterating the value of the neutral axis depth until the
two equations are equal give
Pn1 = 1035 k
Pn2 = 1035 k
M=
n P=
ne 1035(24.54) /12 = 2116 k-ft
εt = 0.00244 , ε y = 0.0021
0.005 − εt
for ε y < εt < 0.005 ; φ = ( φt − φc ) = 0.712
0.005 − ε y
7) Calculate φ ,
φPn = 0.711(1035 ) =
735 kips
φM n = 0.711( 2115 ) =
1504 k-ft.