a.iii. The building requires use of water-based painting materials 10 avold emission OF
unwanted fumes.
3.2 Electrical Design Guidelines
A. ELECTRICAL GENERAL DESIGN GUIDELINES
a. The fit-out design and installation of all electrical works shall be done in accordance
with the provisions of the latest edition of the Philippine Electrical Code, the laws and
ordinances of the local code enforcing authorities, the Electrical Standards set by
Owner and the Technical Specifications for Electrical Works of this project.
b. For Electrical fit-out design purposes the following criteria shall be strictly complied
with:
i, The maximum normal electrical load for each Tenant shall be limited to the
values as shown on the Panelboard Schedule. Any service upgrade beyond
the allocated load shall be submitted to Owner for evaluation. The approval
of the upgrade shall depend on the availability of spare capacity of the
building. Such upgrade shall be for the Tenant's account.
* For studio type units and one bedroom type A units, normal provision
is 70AT, 1P, emergency provision is 20AT, 1P, selected loads only.
¢ For one bedroom type B units and two bedroom units, normal
provision is 100AT, 1P, emergency provision is 20AT, 1P, selected
loads only.
Studio A | Fit-Out Guidelines | Page 18 of 31| Atwerng shat be done in EMT (stowed ant fo 2" dao blow) IMC or
[RSC cond. Uso of PVC const alowed for area embeded on,
{concrete and fr tlsconmuncation ang GATV stom. Foxe metal
onduts shal be used for cop clings (180 max) anon ig atures
Shd motors termination. Condut termination electtes boras shal us he
‘rope ype of adapters or connectors: Use of MICA tubing eal be imed 0
Song of ex inchos (67) on light tures and out teminaton.
‘&Eloerical Sonics Votage shal be 9 paso, 400V Ine 0 tne and single phase, 220
tne fo neu, plus ground, 60 hertz. Single phase toads shall be propery stots
ang Balanced onthe tee phase pares.
4. Al frcesoent amp bghtng furs shal be in enclosed metal box ype Balas shal
be eecontc typo or rapid star igh power factor type ard shal be loca nade he
‘metal box
amp transformers shou nat be installed onthe drop colin,
Covering raterals If provided shall be noncombustible, prelerably gypsum
oar
9. All acational electrical device installed shall be the same type and make as the
tring electra materi ofthe Bulng ox approval equa.
Selected emergency power provision is provided for the Commercial Units ony
eter to panel board sohodule.
PANEL BOARDS:
‘Main Grout Breaker and Branch Circuit breakers shall be bolt-on type with intemal
‘common tp mechanism urless noted ctherise. Plug-in cult breakare are not
‘ccepiable, Panelboards including crcut breakers shall be provided by the Tenart
‘minimum short creat extent shall be 10 KAIC lor ighing & 22 KAIG for main &
‘mote oaes
Grounding iugs shall be provided inside the Merchant spaces for grounding
Connesons of outs and equpment.
Size of the cult breaker ~ Total load Curent shall not exceed eighty percent 80% ot
‘he Circus Breaker ating.
Use of GFCI Circuit Breakers to all Convenint Outlets located at kitchen and tet
‘areas ner the iavatones (about 180m or 6)
c. WIRES AND CABLES
‘lL witog shall be color ~ coded Line 1 — RED, Line 2 ~ YELLOW, Line 8 - BLUE, Ground —
‘GREEN, Neutral - WHITE. Wires 1 be used shall be PHELPS DODGE, DURAFLEX, PHILFEX
‘COLUMBIA. OR wires used for buling viting to have unormly.
Feeder and Cult wires ~ ampere rating of th wir shal be same as the ampere rating ofthe
(Creut Breaker
FFeedor Ines and conduits from electrical rom to Merchants lease area shal be provided by the
Developer. Wios, conduls, and accessories, Le, u-bols, hangers, supports, junaon boxes, pull
boxes, swichas, ot. fr elstica t-out works within the Merchants lazee spaco shal be for the
Merchants account.
Branch Cieuits shall be provided with soparato aquoment ground wires. ithe tenant requires
Independent rounding it shall be forte eran acon endo be ceodnated wih fe Bing
anager
‘There shal be no open wing, ro exposed wires & no dangling wives.
Matile taping to an extension cord isnot alowed
‘Al overhead conduits shall be provided with Independent hanger fod, unistut channel hanger
supponts and accessories.
‘Studio A | Fit-Out Guidelines | Page 19 of $1
FILINVES