ourd
Style.com
143 Leggings
Burda sizes 44, 46, 48, 50, 52
Side length 113 em (44 1/2 ins)
Upper edge of leggings sits 1.5 cm (5/8 in) above
waist
Hem circumference 37 cm (14 1/2 ins)
Materials
Recommended fab
only very elastic fa
: Stretch trouser fabrics. Use
140 cm (55 in) wide imitation leather with cross-
wise stretch; 1.05 ~1.10-1,20-1,30-1.50m (1
4/8-11/8-13/8-1 1/2-13/4 yds}.
1160 cm (63 in) wide stretch jersey: 0.40 m (1/2 yd).
Elastic, 2.5 cm (1 in) wide: 0.90 -_0.95 — 1.00—
1,05- 1.10 m (1-1 1/81 4/8-11/4-11/4
yds),
Preparations
Print the pattern out on letter or Ad sized paper.
Itis very important to not scale the document.
Your pattern will print on multiple pages, which
you will then tile together. Arrange the sheets on
a large, hard and flat surface matching up the
numbers and letters (ie. 6A to 6A). Cut or fold
cone of the sides and match the edge to it’s corre-
sponding side. Then, tape down in place so paper
is secure.
‘Trace the pattern pleces from the pattern sheet
following the lines and markings for style 143 and
your size, Cut apart pieces 21 and 22 on the
marked seam line.
burda style magazine patterns do not have seam
allowance included.
Seam and hem allowance to be added: Seams
and edges 1.5 cm (5/8 in), no allowance on lower
edges of legs.
Cutting and Sewing Instructions
Pattern Pieces 21 and 22
Cutting Out
Jersey:
21 upper front legging piece
22 upper back legging piece
Imitation leather:
21 lower front legging piece
22 lower back legging piece
2x
2x
2x
2x
Copyright 2016 by Verlag GmbH & Co.KG Aenne Burd, Hubert Burd Pat 2, 077652 Offenburg.Allmodels, pattem pleces and drawings are copyrighted, commercial use Is
prohibited. The publisher shall not be lable for damages eaused by improper handing of the cut mate, mproper execution ofthe "ips and insructons, Or improper use of
‘the models are emerging.Sewing
Note: Stitch seams on stretch fabrics with a special
stretch stitch or at a narrow zigzag setting,
Stitch horizontal section seams on front and back
legging pieces. Press seam allowances onto upper
pieces. Topstitch close to seams.
Stitch side seams. Topstitch front pieces close to
seams.
Stitch inside leg seams. Pull one leg into the other,
with right sides facing. Stitch front and back centre
seam as continuous seam, leaving seam open in
back above fold line for elastic.
Turn self-facing on upper edge of legging to inside
on fold line, turn in, and stitch as marked to form
elastic casing, Pull elastic into casing, Sew ends to-
gether for a circumference of 84 ~ 88 - 94-100 -
106 cm (33 ~ 34 3/4 37-39 1/2~41 3/4 ins),
Cutting and Sewing Instructions
Imitation leather, 140 cm wide
Stretch jersey,
160 cm wide
70_CM
fabric fold
Hoe)
Tahege
=]
wehedge
80 _CM
Cut from a double layer of fabric, right side facing in.
Copwight 2016 by Verlag Gmbl 8 Co. KG Aenne Burda, Hubert Burda-Pat 2, D-77652 Ofenbug All model, pattem pleces and drawings ate copyrighted, commercial uses
prohibited. The publsher shall not be Hable far damages caused by improper handing of theeut mata, improper execution ofthe ps and instctons, r improper use of
‘the models are emergingburda
Style.com
Additional Information:
Burda patterns do not include seam and hem allowances. We recommend
adding 1-2 cm (3/8 - 3/4 inch) for seams and 2-5 cm (3/4 - 2 inch/es) for hems.
Refer to your specific pattern instructions for exact measurements.
The fabric requirements are based on the fabric used for the original designs.
‘These amounts will change if you use fabric of a different width. The pattern of
the fabric determines whether all the pieces must be cut in the same direction
or whether some can be reversed to save fabric.
‘The cutting layout printed with the instructions shows the best way to place the
pattern pieces on our original fabric. Fold the fabric double with the right side
facing in. The fabric then has a fold edge and a selvedge edge. When cutting
from a single fabric layer, the right side should face up.
Pattern pieces which are shown in the cutting layout with broken outlines
should be pinned to the fabric with their printed side facing down.
Grey shaded areas in the cutting layout indicate which pieces are to be inter-
faced.
Transfer the pattern piece lines to the wrong side of your fabric with
dressmakers carbon paper. Hand-baste along lines (e.g. for pockets or centre
front) to make them visible on the right side of the fabri
Have fun sewing, and make sure to upload pictures of your finished sewing
project to BurdaStyle.com/projects and link it to the pattern you made it
from!
If you have any questions about the pattern or specific instructions please
email answers@burdastyle.com and your inquiry will be forwarded to one of,
our sewing pattern experts.
Fabrics may shrink when laundered for the first time, especialy those made of cotton,
linen, and rayon. To avoid shrinkage of the finished garment, these fabrics should be
pre-treated (washed and dried before cutting out the fabric pieces). Use the temperature
settings you plan to use forthe finshed garment: if you want to test the amount of shrinkage
Cf your fabric, cut a square of the fabric and measure it exactly Finish the edges, then wash i,
‘and compare the size after washing with the original size.
Symbols
‘Amhole markings
lib gee and ont
‘shan tn save st
rote ine so
Sreereaione. ff ST
efoweageota
Sole oe a
Soe
tution ttonhle Eyelet pening
x —
fot ine
bor thsbroten ine [
then
srfeld'and note
Ising tine
tage pen pece hat cme,
fit on the pater oar sheet wl
‘ul be tapes ogee ah
fave been raced onto patern
et A douse nite
[odes match poms.
tensioning
theater met soeeu you wi need |
Widsgiienthengo ce he |
pte orto pape
‘of te row bythe amount nected
Pat symbot
Fold the pleat inthe drction
ofthe arom
Presse foot
‘A reser foot image incatesseam
eatepatehing nes,
smo
Sedat i ah
Soreaee ate ai one
loadable patterns, scisors indicate oe
Sierts Bat tour on sed
Sim atowsnes) ra
roe
Ad
the acl
Sovnloadable pattern ples, the words are
Shown on eng scams,
nectar: perpen
Inaleate eagesto be
Seam numbers
Agha pen ices
{gener ae ieheated
‘wih the ome som
‘Rumbo Match ples
‘Sahih some numbers,
StivPiacket mark
“rama thik ine that
iments te cutng ine
Incas begining ee
hd ofa packet