‘SPLICING OF WIRES
DIRECTIONS: Below are pictures of common wire splices and joints used in electrical
wiring installations. Practice doing the task by following the steps given. Your performance
will be judged using the rubric:
‘Stops in splicing a rat tail joint
‘Steps
Figures
g
ip the wire insulator at the
of the conductor to be
at about $0 mm. Clean
‘to be.
fe
2. Place the two ends of bare
‘wire in crossed postion.
3. Then, twist the bare
conductors about five to seven
times.
Sieps ins
westem union Tong: t Jol
eps
Figures
1. Strip the wire ends for about
75 mm.
Position about mid halfway
from the insulation
3. Make four to six long twists of
wires,4. Wrap each side of the wire for
about four to five tums as
— ee.
‘Steps in splicing aerial tap joint
Steps Figures
‘+ Strip the tap wire end about 75
mm. and the main wire end
about 25 mm.
+ Place the wires in crossed
position intersecting about 5
mm from the insulation of the
tap wire and the main wire.
+ Bend the tap wire over the
main wire making a long twist.
+ Tum the tap wire around the
main wire making four to five
tums.