Professional Documents
Culture Documents
Fat Rich Dairy Products: B. Tech. (Dairy Technology) DT-2 Resources
Fat Rich Dairy Products: B. Tech. (Dairy Technology) DT-2 Resources
=i Éëëç å=PUK=_ r q q b o l fi
Lesson 38
BUTTEROIL
38.1 Introduction
In countries like India, butteroil has huge market potential since it overcomes the storage
difficulties and the associated cost of low temperature storage. Butteroil can be stored at
ambient temperature for longer duration. It requires less storage space compare to butter.
Anhydrous milk fat(AMF) is the other term for butteroil, it contains less moisture(around
0.1%) then butteroil(around 0.4%).
38.2 Definition
According to FSSR-2011 Butteroil and Anhydrous Milk fat / Anhydrous Butteroil means
the fatty products derived exclusively from milk and/ or products obtained from milk by
means of process which result in almost total removal of water and milk solids not fat. It
shall have pleasant taste and flavour free from off odour and rancidity. It shall be free
from vegetable oil/ fat, animal body fat, mineral oil, added flavour and any other substance
foreign to milk. It may contain permitted food additives such as antioxidant ascorbyl
stearate(500mg/kg maximum), Propyl gallate, Octyl gallate, Ethyl gallate(1000mg/kg
maximum for each)and Butylated hydroxy anisole(BHA, 175mg/kg maximum). It shall
conform to the following requirements.
Looks similar to ghee, pale yellow liquid, majorly constitute of milk fat. Alternatively it can
be called as anhydrous milk fat (AMF). According to FAO/WHO AMF should have min
99.8% fat.
4. Product should have deep yellow colour if it is form cow milk fat and white with
green tinge from buffalo milk fat
Raw cream of 35 – 40% fat content is pasteurized through plat heat exchanger or tubular
heat exchanger. Then it passes through cream concentrator (essentially cream separator) to
achieve a fat percent level of around 75%. Here we can store the cream as intermediary
storage. Cream is then fed to homogenizer for phase inversion (it breaks the fat globule
membrane to release the fat). After phase inversion product again pass through centrifugal
concentrator where the cream fat level is rise to 99.5%. Heating will be done at 95 to 98°C
in a plate heat exchanger. Reduce the moisture content of the product to 0.1% in vacuum
chamber followed cooling to ambient temperature through PHE. Flow diagram depicted
figure 38.1
to holding tank, where it is hold for 20- 30 min to facilitate protein aggregation. Then
butter melt is transferred to centrifugal concentrator, where light phase is concentrated to
99.5% fat. Concentrated light phase is then pumped through plate heat exchanger (PHE)
where it is heated to 90-95°C. Then to vacuum chamber for final moisture adjustment
then back to PHE for cooling to 35 – 40°C for packing. Flow diagram depicted figure
38.2.
Butteroil is filled in containers of various sizes. Filling should be done up to the brim in the
container in such a manner as to exclude maximum oxygen. For households and
restaurants containers of 1 kg to 20 kg are available. For industrial uses drums of minimum
180kg are also available. An inert gas, nitrogen, is used for packing to prevent oxidation.
Butteroil can be stored at ambient temperature since it contains very low amount of
moisture, expected shelf life of product at this storage temperature is about one year.
38.7 Judging
Procedure of examination
38.8 Defects
It is used in the production of recombined milk. It can also be used in the manufacture of
ice cream and in the confectionery industry. Butteroil is also utilized in the production of
various types of fat spreads.
DT-2