MICRO PROGRAMMABLE CONTROLLER
MICRO-1
USERS MANUAL
Compliance with IEC Standards
All units of the MICRO-1 programmable controller are in compliance with the IEC Standards.
For the specifications in compliance with the IEC Standards, see IEC Specifications on pages
‘A-I through A-19.Page
FEATURES .... 4
PART DESCRIPTION . fa 5
SYSTEM CONFIGURATION 6
1. Basic System 0... eeee eee eeeee - 6
2. 1:1 Communication Computer Link System 7
3. 1:N Communication Computer Link System 7
SPECIFICATIONS .......-. +++ 8
SIMPLE OPERATION EXAMPLE . 10
1/0 WIRING . : 14
1. Relay Output Type (Base/Expansion Units) “4
2. Transistor Output Type (Base/Expansion Units) 15
ALLOCATION NUMBERS: W7
INSTRUCTION WORDS 19
START/STOP OPERATION . a 33
1. Start & Stop Using Program Loader . 33
2. Start & Stop by Power Supply 33
3. Stop & Reset by External Signal 34
4, Start & Stop by Special Internal Relay . a 34
CATCH INPUT (Short-pulse Input: 0.5 msec) READ FUNCTION 36
PROGRAMMING p00 37
Program Loader (FC1A- “HLIE) 37
Programming Procedures . . 39
Basic Operating Procedures
FUN Initial Settings
Other Operations . .
Searching for Program Instruction eee eo
Transferring Program
NORPENSMICRO PROGRAMMABLE CONTROLLER
MICRO-1
CONTENTS
Page
MONITORING OPERATION ......-....- sees cove GT
1, Simultaneous Monitoring . 6
2, Sequential Monitoring ........-.66e00e0 weet eeee eee 63
3. Scan Time Monitoring 64
CONNECTION TO FASERIES PLC . 65
1. Connecting FA Series Program Loader to MICRO-1 Base U 65
2. Connecting MICRO-1 Program Loader to FA Series CPU... 66
INSTALLATION & WIRING . 67
1. Installation Location 67
2, Mounting ...........0ceesseeeeeeees . 7
3. Wiring... go . 68
4. Removing Terminal Cover 68
DIMENSIONS ; 69
DIAGNOSTIC FUNCTIONS & MAINTENANCE 70
1. Error Codes .. 7
2. Reading Out Error Contents. . 73
TROUBLESHOOTING PROCEDURES . 74
TYPE LIST ... : 82
PROGRAM KEY OPERATING PROCEDURES . 84
APPENDIX
Programming Sheet
Allocation Table ....-. 62+ 65-5
IEC SPECIFICATIONS .
INDEX .. 2...