2. (a) reduces the diameter of a workpiece along its length 3. (b) I. C engines 4. (a) Jaw clutch is a positive clutch 5. (a) 375.93 mm 6. (d) kg/cm2 7. (d) increase uniformly first and then increase rapidly 8. (d) slenderness ratio, area of cross-section and modulus of elasticity 9. (a) breaking stress 10. (b) size of the drilled or reamed hole 11. (c) 100 MN/m2 12. (b) lower pair 13. (a) sliding and turning pairs 14. (c) utilises a quadrilateral similar to the diagram of mechanism for reciprocating engine 15. (d) worm gear 16. (b) two elements having relative motion 17. (b) displacement 18. (d) a straight line 19. (b) zero 20. (a) As the Reynold’s number increases the friction factor increases in turbulent flow 21. (c) If the pressure on liquid is more than its vapour pressure 22. (b) Eulerian method 23. (c) Irrotational flow 24. (b) Navier-stockes equation of motion 25. (b) the major loss 26. (b) hL = (V2 / 2g) 27. (c) increase the temperature of a liquid of vapour 28. (d) may increase or decrease depending on temperature 29. (d) thermocouple 30. (e) boiler. 31. (d) a physical property of the material 32. (c) 1:2 33. (a) one dimensional case only 34. (c) fourth power of absolute temperature 35. (d) time 36. (d) absorbs heat radiations of all wave lengths falling on it 37. (d) does not vary with temperature and wavelength of the incident ray 38. (d) all of the above 39. (b) kinetic energy of molecules 40. (c) when molecular momentum of the system becomes zero 41. (b) only small range of pressures 42. (c) zero 43. (a) 1 Nm/s 44. (b) 83.14J/kmol°K 45. (b) heat, work and properties of the system 46. (a) reversible engine 47. (c) storm 48. (b) two isentropics and two constant volumes 49. (d) between after-cooler and air receiver 50. (b) conversion of kinetic energy into pressure energy