a®
ABORT STATION
The Abort Station is designed to be wired to the abort terminals of the Agent 6
Release Control Panel (CR 77301). The device consists of a Zinc Alloy
facoplato and a modular ewitch accombly. It ie designed to mount on a emcee con
standard single gang electrical enclosure.
HEMOK
Control Switches
Specifications:
+ Size: TOmm W x 115mm H x 25mm D
+ Weight: 1289 + 5%
+ Materia Zine Alloy
+ Operating Temp.: 0°C ~ 55°C
+ Power: BC 12v 1A,
PIN. OR 88105
RELEASING CIRGUIT DISABLE SWITCH
‘The device consists of a Zinc Alloy faceplate, green LED, amber LED and a
switch assembly. It is designed to mount on a standard single gang
electrical enclosure.
Application
‘The RCDS complies with the requirements of NFPA 72:
+ Specifying @ physical switch to disconnect the release circult in place
of a software controlled disconnect.
+ Creating @ supervisory wunullivn un thie assucialed release panel.
Installation
1, Connect the red and black leads to the 24 VDC auxiliary power terminals
on the release panel. De certain to observe polarity
2. Connect the yellow wires to the supervisory zone on the panel PIN: CR 88205
MAIN-RESERVE SWITCH
The “Main” to “Reserve” Switch is used with systems that incorporate main
and reserve (bank-up) agent storage. The switch have two kinds of dry
contact (COM.IN.C. and COM/N.O.) switch separately to avoid any
interference by different system.
Following a system discharge, reset any field devices. Once all devices are
in a stand-by status, the Main-Resorve Switch may be moved to the
"Reserve" position. The Control Panel may then be reset fo 2 normal mode
for uninterrupted Chemori protection. The empty "Main” containers can be
removed for recharge. After the containers in the “Main” system have been
recharged, the switch may be retumed to the “Main” position.
PIN: CR 60914
‘WER: WOW.CHENORICONM —_EWAIL/SALES@CHEMORLCOM Ray. 2
[Al specilesionsandinformation nested above ae subjected change winoutprornatce, Catalog #SB19CR Ret: CR-902250 SEFTINT